2022 Blue Bird All American School Bus Recalls

Recalls on record Updated July 2026

The 2022 Blue Bird All American School Bus has 10 NHTSA recall campaigns affecting an estimated 63,275 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 2 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.

Recall campaigns

EQUIPMENT 24V758000 2024-10-11 28,479 affected
Defect

Blue Bird Body Company (Blue Bird) is recalling certain 2019-2024 Vision and All American school buses. The emergency exit label operating instructions lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS)…

Consequence

An emergency exit label that is difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.

Remedy

Dealers will replace the emergency exit label, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Blue Bird Customer Service at 478-822-2242. Blue Bird's number for this recall is R23CK (SB).

STRUCTURE 24V543000 2024-07-19 16,708 affected
Defect

Blue Bird Bus Company (Blue Bird) is recalling certain 2019-2023 Vision, All American Front Engine, and All American Rear Engine school buses. An exterior roof joint may have been manufactured with insufficient strength that can allow the roof panels to separate in a crash. As such, these vehicles fail to comply…

Consequence

Roof panels that separate during a crash can increase the risk of injury.

Remedy

Dealers will inspect the roof panel joints and install additional rivets as necessary, free of charge. Owner notification letters were mailed September 17, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242.

SEATS 24V078000 2024-02-07 6,691 affected
Defect

Blue Bird Body Company (Blue Bird) is recalling certain 2020-2024 Vision 2020-2023 All American school buses. The convertible seats may have been incorrectly installed, which can result in an unsecured seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number…

Consequence

An unsecured seat may not adequately restrain an occupant, increasing the risk of injury during a crash.

Remedy

Dealers will inspect and repair the seat, free of charge. Owner notification letters were mailed March 04, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R24CM-SB.

STRUCTURE 23V778000 2023-11-20 6,124 affected
Defect

Blue Bird Body Company (Blue Bird) is recalling certain 2014-2024 All American school buses equipped with 39" High Back seat restraining barriers. The bolts securing the restraining barriers to the floor may separate when fully loaded. As such, these vehicles fail to comply with the requirements of Federal Motor…

Consequence

An unsecured seat restraining barrier may not properly restrain an occupant during a crash, increasing their risk of injury.

Remedy

Dealers will install a longer bolt with rectangular washer and nut, free of charge. Owner notification letters are expected to be mailed January 16, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R23CU-SB. This recall is an expansion of recall number…

ELECTRICAL SYSTEM 23V425000 2023-06-13 1,424 affected
Defect

Blue Bird Body Company (Blue Bird) is recalling certain 2021-2024 All American and 2021-2022 Vision school buses. A software error in the instrument cluster may cause the air pressure gauges and the visual and audio low air warnings to not function. As such, these vehicles fail to comply with the requirements of…

Consequence

Air gauges and warnings that do not alert the driver to air pressure loss can result in driving without functioning brakes, increasing the risk of a crash.

Remedy

Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed July 27, 2023, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R23CH (School Bus).

ELECTRICAL SYSTEM 22V505000 2022-07-14 482 affected
Defect

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American and Vision school buses equipped with Cummins PD7000 Electric Drivetrains containing an electric air compressor. The air compressor housing is improperly grounded, causing electrical voltage greater than 50V AC during operation.

Consequence

An improperly grounded air compressor can cause electric shock, increasing the risk of injury.

Remedy

Dealers will install an electrical ground strap between the compressor motor housing and vehicle chassis, free of charge. Owner notification letters were mailed February 6, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BY-SB.

FUEL SYSTEM, DIESEL 21V312000 2021-05-04 1,053 affected
Defect

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American buses. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

Consequence

A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy

The remedy for this recall is still under development. Owner notification letters were mailed on July 30, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BH-SB.

SERVICE BRAKES, AIR 21V284000 2021-04-22 1,634 affected
Defect

Blue Bird Body Company (Blue Bird) is recalling certain 2020-2022 Vision and All American school buses. A retainer was not properly seated in the SC-3 single check valve and may not provide source air isolation when pressure is applied. As such, these vehicles fail to comply with the requirements of Federal Motor…

Consequence

Unintended spring brake application may occur, increasing the risk of a crash.

Remedy

Dealers will replace the SC-3 check valves, free of charge. Owner notification letters were mailed on November 18, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BE-SB.

ELECTRONIC STABILITY CONTROL (ESC) 21V083000 2021-02-17 60 affected
Defect

Blue Bird Body Company (Blue Bird) is recalling certain 2021-2022 Vision and 2022 All American school buses equipped with hydraulic brakes and electronic stability control (ESC). The Hydraulic Brake control unit (ECU) may not have been programmed correctly, possibly causing the ESC to malfunction.

Consequence

If the electronic stability control does not function properly, it can increase the risk of a crash or injury.

Remedy

Blue Bird will notify owners, and dealers will inspect the hydraulic brake ECU and repair it as necessary, free of charge. The recall began on April 9, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BC-SB.

SEAT BELTS 21V070000 2021-02-12 620 affected
Defect

Blue Bird Body Company (Blue Bird) is recalling certain 2020-2022 Vision and All American buses. The seats with integrated 3-point seat belts may have been installed incorrectly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt…

Consequence

An incorrectly installed seat can increase the risk of injury in the event of a crash.

Remedy

Blue Bird will notify owners, and dealers will inspect the seats and install any missing hardware, as necessary, free of charge. The recall is expected to begin April 9, 2021. Owner notification letters were mailed February 03, 2022. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's…

Complaints by component

ELECTRICAL SYSTEM
1
1fires
STRUCTURE
1
Total complaints2

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“The contact's employer owns a 2022 blue bird conventional. The contact stated that upon further inspection, it was noticed that the battery arms were fracturing at the frame of the bolts. No warning lights were illuminated. The contact related the failure to nhtsa campaign: 17v100000 (structure);…”

STRUCTURE · reported 2025-09-29

“"gov caught fire due to heater malfuction per the fire dept."”

ELECTRICAL SYSTEM · reported 2022-11-23
Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2022 Blue Bird All American School Bus as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.