RecallRepo

2002 Chevrolet Avalanche Recalls

Recalls on record Updated July 2026

The 2002 Chevrolet Avalanche has 2 NHTSA recall campaigns affecting an estimated 5,015,929 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 562 complaints with NHTSA, most often about the service brakes. Last updated July 5, 2026.

Recall campaigns

SERVICE BRAKES, HYDRAULIC 05V379000 2005-08-29 1,353,718 affected
Defect

CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND,…

Consequence

THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN…

STRUCTURE 04V129000 2004-03-17 3,662,211 affected
Defect

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.

Consequence

ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES…

Remedy

DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463,…

Complaints by component

SERVICE BRAKES
54
5crashes2injuries
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
46
9crashes3injuries3deaths
SERVICE BRAKES, HYDRAULIC
37
3crashes1injuries
STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
32
7injuries
PARKING BRAKE
28
ENGINE AND ENGINE COOLING
16
1injuries
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
16
STRUCTURE
14
AIR BAGS
11
11crashes13injuries
TIRES
11
1crashes
Total complaints562

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“The contact owns a 2002 chevrolet avalanche. The contact stated while attempting to stop the vehicle, the brake pedal was firm, and vehicle kept accelerating unintendedly. Several warning lights were illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was…”

SERVICE BRAKES · reported 2023-11-07

“The contact owns a 2002 chevrolet avalanche. The contact stated that while driving at an undisclosed speed, the abs and oil warning lights illuminated. Additionally, the speedometer, the 4-wheel drive function, parking brake, and headlights failed to operate as needed. The instrument panel light…”

POWER TRAIN · reported 2020-11-01

“The contact owns a 2002 chevrolet avalanche. The contact stated that while driving at an undisclosed speed, the abs and oil warning lights illuminated. Additionally, the speedometer, the 4-wheel drive function, parking brake, and headlights failed to operate as needed. The instrument panel light…”

SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT · reported 2020-11-01

“The contact owns a 2002 chevrolet avalanche. The contact stated that while driving at an undisclosed speed, the abs and oil warning lights illuminated. Additionally, the speedometer, the 4-wheel drive function, parking brake, and headlights failed to operate as needed. The instrument panel light…”

EXTERIOR LIGHTING · reported 2020-11-01

“Brake lines are made out of defective materials gm knows they have a problem the lines rust out prematurely . The first one blew out I was backing in a parking space pedal went to the floor. The second one blew at a traffic light pushed on the brake went thru the red light dodged traffic .the…”

SERVICE BRAKES · reported 2015-12-26

“While driving at 65 mph the engine cut out. Could be the crankshaft position sensor. The truck is a 2500 with an 8.1l engine. Similar issues that the 2001 was recalled for. Same engine and cps as the 2001 but not included in the original recall. This has happened several times at various speeds.”

ENGINE · reported 2015-08-03

“When traveling at low speeds, >5mph, the abs activates and vehicle continues on to the point of entering traffic. This occurs frequently and without warning, at stop signs and even just pulling out of private driveway into traffic. My local mechanic ran a diagnostic test and indicated that a front…”

SERVICE BRAKES · reported 2015-07-30

“While driving my truck and towing a trailer, I lost almost all my braking power. Had to down shift and use the emergency brake to stop. Found that a brake line from the master cylinder to the anti-lock brake module (which is mounted under the drivers seat, great place) had rusted through and blew…”

SERVICE BRAKES · reported 2015-01-02

Defect investigations

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation EA02015 Opened 2002-08-01 · closed 2004-01-12

THROTTLE STICKING CLOSED

THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN…

Investigation EA04005 Opened 2004-02-19 · closed 2004-09-28

TAILGATE CABLE BREAKAGE

GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR…

Investigation EA04005 Opened 2004-02-19 · closed 2004-09-28

TAILGATE CABLE BREAKAGE

GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR…

Investigation EA04005 Opened 2004-02-19 · closed 2004-09-28

TAILGATE CABLE BREAKAGE

GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR…

Investigation EA04005 Opened 2004-02-19 · closed 2004-09-28

TAILGATE CABLE BREAKAGE

GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR…

Investigation EA04005 Opened 2004-02-19 · closed 2004-09-28

TAILGATE CABLE BREAKAGE

GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR…

Investigation EA04005 Opened 2004-02-19 · closed 2004-09-28

TAILGATE CABLE BREAKAGE

GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR…

Investigation EA04012 Opened 2004-04-30 · closed 2005-02-28

HYDRAULIC PUMP FAILRES

GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE…

Investigation EA04012 Opened 2004-04-30 · closed 2005-02-28

HYDRAULIC PUMP FAILRES

GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE…

Investigation PE05020 Opened 2005-04-28 · closed 2005-09-13

UNWANTED LOW-SPEED ABS ACTIVATION

IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES…

Investigation PE05020 Opened 2005-04-28 · closed 2005-09-13

UNWANTED LOW-SPEED ABS ACTIVATION

IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES…

Investigation PE06016 Opened 2006-05-04 · closed 2006-09-14

CRANK POSITION SENSOR FAILURE - STALL

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE06-016) ON MAY 4, 2006 BASED ON ELEVEN VEHICLE OWNER QUESTIONNAIRES (VOQS) AND EARLY WARNING (EWR) DATA ALLEGING SUDDEN ENGINE SHUTDOWN WHILE DRIVING AS A RESULT OF CRANK POSITION SENSOR FAILURES IN MY 2001-2002 GENERAL MOTORS C/K PLATFORM…

Investigation PE06016 Opened 2006-05-04 · closed 2006-09-14

CRANK POSITION SENSOR FAILURE - STALL

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE06-016) ON MAY 4, 2006 BASED ON ELEVEN VEHICLE OWNER QUESTIONNAIRES (VOQS) AND EARLY WARNING (EWR) DATA ALLEGING SUDDEN ENGINE SHUTDOWN WHILE DRIVING AS A RESULT OF CRANK POSITION SENSOR FAILURES IN MY 2001-2002 GENERAL MOTORS C/K PLATFORM…

Investigation PE10010 Opened 2010-03-30 · closed 2011-01-05

Brake line corrosion failure

The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010…

Investigation PE10010 Opened 2010-03-30 · closed 2011-01-05

Brake line corrosion failure

The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2002 Chevrolet Avalanche as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.