1996 Chevrolet K1500 Recalls
No NHTSA recalls on record for the 1996 Chevrolet K1500. That means NHTSA has no open safety campaign for this vehicle — it does not guarantee the absence of problems. Owners have filed 108 complaints with NHTSA, most often about the visibility. Last updated July 5, 2026.
Complaints by component
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.
“My vehicle failed massachusetts seat belt test. They dont lock when pulled on quickly. I have removed and inspected them and it appears to me that the mechanism itself is not capable of passing this test I am believing that the test has been implemented after the manufacture of this particular…”
“1996 chevrolet silverado. Consumer writes in regards to vehicle engine problems. *smd the consumer noticed anti-freeze on the ground toward the rear of the engine. He took the vehicle took the dealer, but they were unable to find a problem. A gm service manager stated, they were aware of coolant…”
“Uniroyal laredo p245-r16 tires have dry-rot cracks next to tread blocks after less than five years and 24,000 miles on vehicle. *tr”
“The driver side power bucket seat released and dropped while I was driving, it will not support the weight of a driver. I have since put a scissor lift jack underneath it to hold it up. This is a big safety issue. I being a licensed p&c insurance agent here in arizona - know all about…”
“Tl* the contact owns a 1996 chevrolet k1500. While driving approximately 65 mph, the air bag warning light illuminated. The contact stated that he inspected the air bag sensor and discovered that it was severely rusted. The contact removed the part and contacted both the dealer and manufacturer in…”
“So far, I have replaced a cruise control four times in five years from salvage, in every case, the only parts to fail are the same two plastic gears worth about $5 retail. Since gm will not sell repair parts, the replacement of the unit is over $500. I would understand if I had four different…”
“Tl*the contact owns a 1996 chevrolet k1500. The fuel pump assembly failed. The wires were too small a gauge for the load. The plastic insulation caused the wires to over heat and it burned down to the fuel tank. The contact showed the parts to the dealer and they stated that they have never seen…”
“Failing diesel injection pump on 1996 chevrolet k1500 pickup with 6.5l diesel engine causes engine to stall when approaching a stop, rendering power steering and power brakes inoperable. This is a common problem on 1994 through 1999 gm vehicles equipped with this engine. Dealer diagnosed the…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1996 Chevrolet K1500 as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.