RecallRepo

2000 Chevrolet Malibu Recalls

Recalls on record Updated July 2026

The 2000 Chevrolet Malibu has 3 NHTSA recall campaigns affecting an estimated 6,591,676 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 1,379 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.

Recall campaigns

ELECTRICAL SYSTEM 14V400000 2014-07-03 5,877,718 affected
Defect

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3,…

Consequence

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

EXTERIOR LIGHTING 03V327000 2003-08-28 670,740 affected
Defect

CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.

Consequence

WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.

Remedy

DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

FUEL SYSTEM, GASOLINE 99V302000 1999-10-29 43,218 affected
Defect

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN…

Consequence

IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.

Remedy

DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.

Complaints by component

ELECTRICAL SYSTEM
128
3crashes1fires1injuries
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
81
2crashes
EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH
74
2crashes
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
68
2crashes1injuries
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
58
7crashes4injuries3deaths
ENGINE AND ENGINE COOLING
56
1crashes1fires
EXTERIOR LIGHTING:TURN SIGNAL
56
EXTERIOR LIGHTING
48
2crashes2injuries
ENGINE AND ENGINE COOLING:COOLING SYSTEM
36
EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS
34
1fires
Total complaints1,379

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Tl* the contact owns a 2000 chevrolet malibu. The contact stated that the vehicle failed to start. The contact shifted the vehicle into neutral, turn the switch to the off position then back to the on position and the vehicle started. The contact also stated that while driving 45 or 55 mph, the…”

ELECTRICAL SYSTEM · reported 2020-09-16

“Tl* the contact owns a 2000 chevrolet malibu. The contact stated that the vehicle failed to start. The contact shifted the vehicle into neutral, turn the switch to the off position then back to the on position and the vehicle started. The contact also stated that while driving 45 or 55 mph, the…”

ENGINE · reported 2020-09-16

“I wanted to let you know about an experience at discount tire 580 w telegraph washington utah. And you can forward this to any regulating agency.from my knowledge, when two tires are purchased new, it is required to mount them on the front of the vehicle if it is front wheel drive. And move the…”

TIRES · reported 2020-05-06

“I've replaced battery, head gaskets, overflow tank, air system connectors, water pump, pcv valve, evap canister, spark plugs, spark plug wires, radiator, camshaft sensor, coolant temp sensor, but my car is still leaking coolant from underneath lower intake manifold and isn't trying to start. I've…”

ENGINE · reported 2020-04-19

“I've replaced battery, head gaskets, overflow tank, air system connectors, water pump, pcv valve, evap canister, spark plugs, spark plug wires, radiator, camshaft sensor, coolant temp sensor, but my car is still leaking coolant from underneath lower intake manifold and isn't trying to start. I've…”

FUEL/PROPULSION SYSTEM · reported 2020-04-19

“I've replaced battery, head gaskets, overflow tank, air system connectors, water pump, pcv valve, evap canister, spark plugs, spark plug wires, radiator, camshaft sensor, coolant temp sensor, but my car is still leaking coolant from underneath lower intake manifold and isn't trying to start. I've…”

VISIBILITY/WIPER · reported 2020-04-19

“Tl* the contact owns a 2000 chevrolet malibu. The contact smelled fuel when the vehicle was parked in the garage. There was no warning indicator illuminated. The dealer and manufacturer were not notified. The vehicle was not diagnosed or repaired. The failure mileage was approximately 137,000.”

FUEL/PROPULSION SYSTEM · reported 2019-10-01

“Tl* the contact owns a 2000 chevrolet malibu. While driving and attempting to switch lanes, the turn signals and hazard lights failed to function. There were no warning indicators illuminated. The vehicle was not taken to a dealer or an independent mechanic for diagnostic testing. The manufacturer…”

EXTERIOR LIGHTING · reported 2019-07-20

Defect investigations

Investigation EA02028 Opened 2002-09-30 · closed 2003-12-30

ERRATIC FUEL GAUGE

ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS…

Investigation EA02028 Opened 2002-09-30 · closed 2003-12-30

ERRATIC FUEL GAUGE

ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS…

Investigation EA02037 Opened 2002-12-23 · closed 2003-09-05

TURN SIGNAL FAILURES

BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY…

Investigation EA02037 Opened 2002-12-23 · closed 2003-09-05

TURN SIGNAL FAILURES

BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY…

Investigation EA02037 Opened 2002-12-23 · closed 2003-09-05

TURN SIGNAL FAILURES

BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY…

Investigation EA02037 Opened 2002-12-23 · closed 2003-09-05

TURN SIGNAL FAILURES

BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY…

Investigation PE02064 Opened 2002-08-22 · closed 2002-12-23

TURN SIGNAL FAILURE

ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT…

Investigation PE02064 Opened 2002-08-22 · closed 2002-12-23

TURN SIGNAL FAILURE

ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT…

Investigation PE02064 Opened 2002-08-22 · closed 2002-12-23

TURN SIGNAL FAILURE

ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT…

Investigation PE02064 Opened 2002-08-22 · closed 2002-12-23

TURN SIGNAL FAILURE

ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT…

Investigation PE02066 Opened 2002-09-06 · closed 2003-11-03

ENGINE STALL DUE TO FUEL STARVATION

ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED…

Investigation PE02066 Opened 2002-09-06 · closed 2003-11-03

ENGINE STALL DUE TO FUEL STARVATION

ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED…

Investigation PE02066 Opened 2002-09-06 · closed 2003-11-03

ENGINE STALL DUE TO FUEL STARVATION

ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED…

Investigation PE02066 Opened 2002-09-06 · closed 2003-11-03

ENGINE STALL DUE TO FUEL STARVATION

ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED…

Investigation RQ04005 Opened 2004-06-18 · closed 2004-11-30

TURN SIGNAL FAILURES

GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS…

Investigation RQ04005 Opened 2004-06-18 · closed 2004-11-30

TURN SIGNAL FAILURES

GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS…

Investigation SQ00004 Opened 2000-02-02 · closed 2001-01-19

ACCELERATOR CABLE DETACHES FROM THROTTLE

There is no summary currently available

Investigation SQ01002 Opened 2001-01-26 · closed 2002-09-30

ERRATIC FUEL GAUGE

There is no summary currently available

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2000 Chevrolet Malibu as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.