RecallRepo

2003 Chevrolet Tahoe Recalls

Recalls on record Updated July 2026

The 2003 Chevrolet Tahoe has 4 NHTSA recall campaigns affecting an estimated 1,432,480 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 628 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.

Recall campaigns

SEAT BELTS 05V163000 2005-04-22 1,359,824 affected
Defect

ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT,…

Consequence

A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.

Remedy

DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT…

SERVICE BRAKES, HYDRAULIC 04V045000 2004-02-04 68,875 affected
Defect

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

Consequence

CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.

Remedy

DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.

STRUCTURE 03V094000 2003-03-07 3,674 affected
Defect

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE…

Consequence

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Remedy

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

STRUCTURE 03V037000 2003-02-06 107 affected
Defect

CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.

Consequence

AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.

Remedy

DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE…

Complaints by component

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
124
SERVICE BRAKES
84
6crashes
ELECTRICAL SYSTEM
65
5fires1injuries
STEERING
30
4crashes5injuries
VEHICLE SPEED CONTROL
26
2crashes
AIR BAGS
16
5crashes3injuries1deaths
SERVICE BRAKES, HYDRAULIC
16
1crashes
FUEL SYSTEM, GASOLINE
14
SEATS
13
2fires1injuries
ENGINE AND ENGINE COOLING
11
2fires3injuries
Total complaints628

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“When in drive the car will not go into 3rd gear. It slips from. 2nd and back passes 3rd gear completely and goes into 4th gear and the engine revs up/rpm. The transmition filter/screen has been replaced and all transmission fluids were drained and flushed and replaced with new transmittion fluids.…”

POWER TRAIN · reported 2022-10-02

“I bought my 2003 chevy tahoe used and as is at a dealership for $10,000. Yes, I've been robbed. The truck is in great looking condition. Has a little bit of superficial dings and a couple dents but overall exterior is great. Interior isn't shabby. Has wear on the driver's seat but not bad. The…”

ELECTRICAL SYSTEM · reported 2022-04-04

“I bought my 2003 chevy tahoe used and as is at a dealership for $10,000. Yes, I've been robbed. The truck is in great looking condition. Has a little bit of superficial dings and a couple dents but overall exterior is great. Interior isn't shabby. Has wear on the driver's seat but not bad. The…”

VEHICLE SPEED CONTROL · reported 2022-04-04

“I bought my 2003 chevy tahoe used and as is at a dealership for $10,000. Yes, I've been robbed. The truck is in great looking condition. Has a little bit of superficial dings and a couple dents but overall exterior is great. Interior isn't shabby. Has wear on the driver's seat but not bad. The…”

SEATS · reported 2022-04-04

“The cable on the rear passenger seat is broken and can't get seat down to escape in an emergency.”

SEATS · reported 2021-06-03

“Well my air bag light stay on never goes over and my driver seat belt does not even lock at all. Then I keep hear this popping noise that come from hub and shocks and nothing on my dash works 1st it started off by I couldnt see what gear I was in. My driver seat u push the button to go forward it…”

AIR BAGS · reported 2020-12-16

“Well my air bag light stay on never goes over and my driver seat belt does not even lock at all. Then I keep hear this popping noise that come from hub and shocks and nothing on my dash works 1st it started off by I couldnt see what gear I was in. My driver seat u push the button to go forward it…”

SERVICE BRAKES · reported 2020-12-16

“Well my air bag light stay on never goes over and my driver seat belt does not even lock at all. Then I keep hear this popping noise that come from hub and shocks and nothing on my dash works 1st it started off by I couldnt see what gear I was in. My driver seat u push the button to go forward it…”

SEAT BELTS · reported 2020-12-16

Defect investigations

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation EA11001 Opened 2011-01-05 · closed 2015-04-08

Brake line corrosion failure

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states…

Investigation EA11001 Opened 2011-01-05 · closed 2015-04-08

Brake line corrosion failure

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states…

Investigation PE03026 Opened 2003-06-12 · closed 2003-11-03

STEEL WHEEL RIM FRACTURE

THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN…

Investigation PE03026 Opened 2003-06-12 · closed 2003-11-03

STEEL WHEEL RIM FRACTURE

THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN…

Investigation PE03026 Opened 2003-06-12 · closed 2003-11-03

STEEL WHEEL RIM FRACTURE

THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2003 Chevrolet Tahoe as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.