RecallRepo

2006 Chevrolet Uplander Recalls

Recalls on record Updated July 2026

The 2006 Chevrolet Uplander has 3 NHTSA recall campaigns affecting an estimated 37,734 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 275 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.

Recall campaigns

SUSPENSION 10V110000 2010-03-19 5,375 affected
Defect

THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.

Consequence

A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.

EQUIPMENT 06V051000 2006-02-15 291 affected
Defect

CERTAIN CARGO VANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARDS NO. 110, "TIRE SELECTION AND RIMS" AND NO. 120. "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE CARGO VANS WERE SHIPPED WITHOUT A TIRE AND LOADING INFORMATION LABELS BECAUSE THEY WERE…

Consequence

WITHOUT THE PROPER LABELS, OWNERS MAY BE UNAWARE OF THE CORRECT TIRE SIZE AND MAY OVERLOAD THESE VEHICLES.

Remedy

OWNERS WILL BE PROVIDED WITH NEW TIRE AND LOADING INFORMATION LABELS AND CERTIFICATION LABELS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM. THE RECALL BEGAN ON MARCH 15, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.

EQUIPMENT 05V552000 2005-12-07 32,068 affected
Defect

CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.

Consequence

A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy

OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT…

Complaints by component

ELECTRICAL SYSTEM
35
STEERING
24
3crashes1injuries
STRUCTURE:BODY:DOOR
21
1injuries
SUSPENSION
13
1crashes
FUEL SYSTEM, GASOLINE
11
1crashes1injuries
STRUCTURE:BODY
10
1injuries
LATCHES/LOCKS/LINKAGES
9
1fires
TIRES
9
1crashes
ELECTRONIC STABILITY CONTROL (ESC)
8
1crashes
SERVICE BRAKES
8
Total complaints275

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“The contact owns a 2006 chevrolet uplander. The contact stated while driving 50 mph, the contact heard an abnormal noise and noticed that the rear driver’s side door had intermittently became inoperable. The check fuel cap warning light was illuminated. The vehicle had not been diagnosed. The…”

STRUCTURE:BODY:DOOR · reported 2022-10-13

“Have a braun van where I was sold a unit that the rails and floor are rust out and van is getting ready to split in half was not disclosed that it was ther and the unit had a recall in 2016 purchased ot in 2018”

UNKNOWN OR OTHER · reported 2021-09-01

“While driving on highway, car suddenly shifted into neutral and I was unable to get it back in gear. Garage said it needs a new transmission. I was almost hit from car behind because I suddenly had lose of power. No warning lights or any issues indicating something was wrong prior to this…”

POWER TRAIN · reported 2021-08-04

“This has happened several times me and my grand daughter are headed out shopping on highway 26 in oregon summit hiway the rig just shuts down ckicking the doors windows made funny noise and gas doesn't read full when full ,lights dime at night dash lights go out you have to wiggle the little dash…”

ELECTRICAL SYSTEM · reported 2021-01-09

“This has happened several times me and my grand daughter are headed out shopping on highway 26 in oregon summit hiway the rig just shuts down ckicking the doors windows made funny noise and gas doesn't read full when full ,lights dime at night dash lights go out you have to wiggle the little dash…”

FUEL/PROPULSION SYSTEM · reported 2021-01-09

“This has happened several times me and my grand daughter are headed out shopping on highway 26 in oregon summit hiway the rig just shuts down ckicking the doors windows made funny noise and gas doesn't read full when full ,lights dime at night dash lights go out you have to wiggle the little dash…”

EXTERIOR LIGHTING · reported 2021-01-09

“Air bags failed to deploy when a dump truck driver ran a red light on the highway at 50+mph without hitting his breaks at all. I was at the intersecting light that was green so I had just started to pull into the intersection to cross over the highway.the front driver's side quarter panel is…”

AIR BAGS · reported 2020-11-13

“Air bags failed to deploy when a dump truck driver ran a red light on the highway at 50+mph without hitting his breaks at all. I was at the intersecting light that was green so I had just started to pull into the intersection to cross over the highway.the front driver's side quarter panel is…”

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING · reported 2020-11-13

Defect investigations

Investigation EA07019 Opened 2007-12-11 · closed 2009-02-23

POWER SLIDING DOOR

ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS…

Investigation EA07019 Opened 2007-12-11 · closed 2009-02-23

POWER SLIDING DOOR

ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS…

Investigation EA07019 Opened 2007-12-11 · closed 2009-02-23

POWER SLIDING DOOR

ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS…

Investigation PE07044 Opened 2007-08-16 · closed 2007-12-11

POWER SLIDING DOOR OPENING

ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND…

Investigation PE07044 Opened 2007-08-16 · closed 2007-12-11

POWER SLIDING DOOR OPENING

ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND…

Investigation PE07044 Opened 2007-08-16 · closed 2007-12-11

POWER SLIDING DOOR OPENING

ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2006 Chevrolet Uplander as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.