2004 Collins Super Bantam Recalls

COLLINS IS RECALLING CERTAIN MODEL YEAR 2002-2011 BANTAM, GRAND BANTAM, AND SUPER BANTAM SCHOOL BUSES MANUFACTURED FROM OCTOBER 2002 THROUGH MAY 20, 2011, FOR FAILING TO CONFORM TO THE LEG PROTECTION ZONE IMPACT REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 222 "SCHOOL BUS PASSENGER SEATING AND CRASH…

IN THE EVENT OF A VEHICLE CRASH, THE VEHICLE OCCUPANTS MAY NOT BE ADEQUATELY PROTECTED AND MAY SUSTAIN INJURIES.

COLLINS WILL NOTIFY OWNERS AND DEALERS WILL INSTALL ADDITIONAL FOAM PADDING UNDER THE UPHOLSTERY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 18, 2011. OWNERS MAY CONTACT COLLINS BUS AT 1-800-533-1850.

CERTAIN 2004 MY BANTAM AND SUPER BANTAM SCHOOL BUSES MANUFACTURED BETWEEN JULY 2004 AND NOVEMBER 2004. THE AMOUNT OF ADHESIVE APPLIED TO THE ROOF SEAMS IS INADEQUATE FOR THE TYPE OF ADHESIVE USED WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, SCHOOL BUS BODY JOINT…

IN THE EVENT OF A CRASH, THE JOINTS MAY COME APART AND INDIVIDUAL INTERIOR CEILING SKINS COULD CAUSE HARM TO THE OCCUPANTS OF THE BUS.

DEALERS WILL CORRECT THE BUSES BY ADDING TWO ADDITIONAL SCREWS BETWEEN THE CURRENT SCREWS THAT ATTACH THE SEAMS OF THE CEILING SKINS TO THE STRUCTURAL ROOF BOWS. THE RECALL BEGAN ON DECEMBER 14, 2005. OWNERS MAY CONTACT COLLINS AT 1-800-533-1850.

CERTAIN 2002-2005 MY COLLINS BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES EQUIPPED WITH SPECIALTY MFG "5" SERIES STOP ARMS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND,…

SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

COLLINS BUS WILL NOTIFY ITS CUSTOMERS AND THE ORIGINAL SWITCH WILL BE REPLACED FREE OF CHARGE WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN OCTOBER 12, 2005. CUSTOMERS MAY CONTACT…

CERTAIN 2002-2005 MY COLLINS BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES EQUIPPED WITH "5" SERIES STOP ARMS. THESE SCHOOL BUSES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY,…

SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

COLLINS WILL NOTIFY ALL ITS CUSTOMERS OF THIS CAMPAIGN. FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, COLLINS IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, COLLINS WILL REPLACE THE SWITCH UPON OWNER REQUEST. FOR THOSE CUSTOMERS…

CERTAIN COLLINS MY 2002-2005 BANTAM, SUPER BANTAM, AND GRAND BANTAM MODEL SCHOOL BUSES MANUFACTURED BETWEEN APRIL 22, 2002, AND APRIL 27, 2005. THESE BUSES WERE EQUIPPED WITH A BENCH-STYLE SINGLE PASSENGER SEATS HAVING A LOWER CUSHION SURFACE OF 24 INCHES IN WIDTH. THESE SEATS SHOULD HAVE A SEATING SURFACE OF ONLY…

THESE SEATS SHOULD HAVE A SEATING SURFACE OF ONLY 22 INCHES WIDE TO HAVE A SINGLE DESIGNATED SEATING POSITION. BECAUSE THE 24 INCH CUSHION IS WIDER THAN 22 INCHES, THE POTENTIAL EXISTS FOR TWO PASSENGERS TO BE SEATED IN THIS SEAT. A SECOND PASSENGER WOULD NOT HAVE AN AVAILABLE SEAT BELT FOR RESTRAINT AND MAY BE…

COLLINS WILL NOTIFY ITS CUSTOMERS AND REPLACE THE 24 INCH SEAT CUSHION WITH A 22 INCH SEAT CUSHION FREE OF CHARGE. THE RECALL BEGAN APRIL 29, 2005. OWNERS MAY CONTACT COLLINS CUSTOMER SERVICE AT 1-800-533-1850.

CERTAIN 2002 THRU 2005 COLLINS BANTAM AND SUPER BANTAM SCHOOL BUSES MANUFACTURED BETWEEN SEPTEMBER 18, 2002, AND JANUARY 17, 2005. THE PROTECTIVE RUBBER PARTS THAT COVER THE FUEL LINES TO PREVENT CONTACT WITH METAL EDGES MAY BE MISSING.

THE FUEL LINES MAY BE CUT RESULTING IN FUEL SPILLAGE AND IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

CUSTOMERS WILL BE NOTIFIED TO TAKE THEIR BUSES TO AN AUTHORIZED DEALER FOR FREE REPAIR. DEALERS WILL INSPECT THE FUEL LINES AND INSTALL THE PROTECTIVE RUBBER COVERING SHOULD IT BE MISSING. IF THE FUEL LINES ARE DAMAGED, DEALERS WILL REPLACE THE FUEL LINES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 21, 2005. …