RecallRepo

2005 Dodge Caravan Recalls

Recalls on record Updated July 2026

The 2005 Dodge Caravan has 4 NHTSA recall campaigns affecting an estimated 851,908 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 691 complaints with NHTSA, most often about the latches/locks/linkages. Last updated July 5, 2026.

Recall campaigns

AIR BAGS 10V008000 2010-01-11 308,950 affected
Defect

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA,…

Consequence

IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.

Remedy

CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

AIR BAGS 07V192000 2007-05-03 270,958 affected
Defect

CERTAIN MINIVANS ARE BEING RECALLED THAT WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE 27 STATES PLUS THE DISTRICT OF COLUMBIA THAT USE GREATER AMOUNTS OF SALT FOR WINTER ROAD DEICING. THE UP-FRONT (UF) AIR BAG SENSORS THAT CONTAIN BRASS BUSHINGS INSTALLED IN THESE VEHICLES MAY CORRODE AND CRACK ALLOWING…

Consequence

IN ONE OF THESE CRASHES, WITH ONE OR BOTH OF THE VEHICLE'S UF SENSORS INOPERATIVE, THE OCCUPANTS WILL NOT BENEFIT FROM THE ENHANCED AIR BAG PROTECTION THAT THESE SENSORS WOULD PROVIDE.

Remedy

FOR VEHICLES REGISTERED IN THE RECALL STATES, DEALERS WILL REPLACE THE ORIGINAL UF AIR BAG SENSORS WITH ONES WITH GREATER CORROSION RESISTANCE. VEHICLES REGISTERED IN OTHER STATES WILL OBTAIN A LIFETIME FREE REPLACEMENT OF ANY UF SENSOR THAT FAILS. THE CAMPAIGN BEGAN ON JULY 2, 2007. OWNERS MAY CONTACT…

VISIBILITY 06V067000 2006-03-08 268,800 affected
Defect

ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.

Consequence

DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

SEAT BELTS 04V047000 2004-02-03 3,200 affected
Defect

AFTER PERFORMING THE NCAP TEST, IT WAS DISCOVERED THAT ON CERTAIN MINIVANS EQUIPPED WITHOUT THE AVAILABLE "STOW 'N GO" SEATING OPTION, THE RIGHT FRONT SEAT BELT RETRACTOR ASSEMBLY MAY HAVE BEEN IMPROPERLY ASSEMBLED.

Consequence

AS A RESULT, THE SEAT BELT MAY NOT PROPERLY RESTRAIN THE OCCUPANT DURING CERTAIN CRASH CONDITIONS, WHICH CAN INCREASE THE RISK OF INJURY.

Remedy

DEALERS WILL INSPECT THE RETRACTOR ASSEMBLIES AND ANY SEAT BELT ASSEMBLY THAT DOES NOT HAVE THE STAKE WILL BE REPLACED. OWNER NOTIFICATION BEGAN ON FEBRUARY 23, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Complaints by component

LATCHES/LOCKS/LINKAGES
193
ELECTRICAL SYSTEM
113
EXTERIOR LIGHTING
68
1crashes
AIR BAGS
22
2crashes2injuries
FUEL/PROPULSION SYSTEM
22
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
17
STEERING
16
1crashes
FUEL SYSTEM, GASOLINE
12
UNKNOWN OR OTHER
11
1crashes2injuries
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
10
Total complaints691

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Air bag light stays on, even with seat belt attached, so this means air bag is not working, not sure driver side, or passenger. Went to dodge dealer, they would not fix it!!”

AIR BAGS · reported 2022-08-04

“The door locks do not work for the sliding doors or the passenger side of the vehicle. We tried to fix this issue by checking the door lock fuse out to make sure it was okay, and it was. The driver's side is the only one that locks. The passenger door lock will not push down and lock when pressed…”

STRUCTURE:BODY · reported 2021-06-07

“The door locks do not work for the sliding doors or the passenger side of the vehicle. We tried to fix this issue by checking the door lock fuse out to make sure it was okay, and it was. The driver's side is the only one that locks. The passenger door lock will not push down and lock when pressed…”

ELECTRICAL SYSTEM · reported 2021-06-07

“Tl* the contact owns a 2005 dodge caravan. The contact stated that a smog test detected a fuel leak from the fuel tank. There were no warning lights illuminated. The contact stated that there was a strong fuel odor outside of the vehicle prior to the smog test being performed. The vehicle was not…”

FUEL/PROPULSION SYSTEM · reported 2020-02-18

“Tl* the contact owns a 2005 dodge caravan. While driving 30 mph, the brake pedal was depressed, but the vehicle failed to stop. Also, the check engine indicator illuminated. The contact also mentioned that there was a strong odor of fuel inside the vehicle. As a result, the contact's vehicle…”

UNKNOWN OR OTHER · reported 2019-11-22

“Remote randomly will not lock/ unlock doors. Pull the battery cable and remote works. Chrysler sent out tsb 08-040-04 on subject. They have a glitch in original software and seems unfair that consumer must pay to have it fixed. Sliding doors do not have keys to lock so one must crawl through the…”

ELECTRICAL SYSTEM · reported 2019-03-30

“Tl* the contact owned a 2005 dodge caravan. While driving 40 mph, the steering wheel seized and caused the contact to crash into a guardrail. There were no injuries. The airs bags did not deploy. A police report was filed. The vehicle was towed by an independent towing company to a salvage lot…”

STEERING · reported 2019-01-08

“When pumping gasoline into the tank, within a few seconds the gasoline backlows and turns off the pump. In order to get 5 gallons into the tank it may take 20 stops, wait & starts which may take 5 minutes. The charcoal vapor trap is working fine since the hose to it from the gasoline tank was…”

FUEL/PROPULSION SYSTEM · reported 2018-12-15

Defect investigations

Investigation AQ10001 Opened 2010-11-18 · closed 2015-12-28

Fleet Vehicle Recall Completion Audit

On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary…

Investigation DP14002 Opened 2014-09-05 · closed 2015-04-06

Engine Stall After Refueling

This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand…

Investigation EA06003 Opened 2006-03-08 · closed 2007-05-22

FRONT AIR BAG CRASH SENSOR FAILURE

DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION…

Investigation EA06003 Opened 2006-03-08 · closed 2007-05-22

FRONT AIR BAG CRASH SENSOR FAILURE

DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION…

Investigation EA11010 Opened 2011-09-06 · closed 2012-11-29

Loss of headlight illumination

The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights…

Investigation EA11010 Opened 2011-09-06 · closed 2012-11-29

Loss of headlight illumination

The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights…

Investigation EA11010 Opened 2011-09-06 · closed 2012-11-29

Loss of headlight illumination

The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights…

Investigation EA11010 Opened 2011-09-06 · closed 2012-11-29

Loss of headlight illumination

The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights…

Investigation PE05061 Opened 2005-11-10 · closed 2006-03-08

FRONT AIR BAG CRASH SENSOR FAILURE

THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS…

Investigation PE05061 Opened 2005-11-10 · closed 2006-03-08

FRONT AIR BAG CRASH SENSOR FAILURE

THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS…

Investigation PE10022 Opened 2010-07-12 · closed 2011-09-13

Loss of Headlight Illumination

To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one…

Investigation PE10022 Opened 2010-07-12 · closed 2011-09-13

Loss of Headlight Illumination

To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one…

Investigation PE10022 Opened 2010-07-12 · closed 2011-09-13

Loss of Headlight Illumination

To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one…

Investigation RQ09003 Opened 2009-07-01 · closed 2010-02-18

FRONT AIR BAG CRASH SENSOR FAILURE

CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND…

Investigation RQ09003 Opened 2009-07-01 · closed 2010-02-18

FRONT AIR BAG CRASH SENSOR FAILURE

CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND…

Investigation RQ09003 Opened 2009-07-01 · closed 2010-02-18

FRONT AIR BAG CRASH SENSOR FAILURE

CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2005 Dodge Caravan as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.