RecallRepo

2007 Fleetwood Excursion Recalls

Recalls on record Updated July 2026

The 2007 Fleetwood Excursion has 4 NHTSA recall campaigns affecting an estimated 91,976 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 5 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.

Recall campaigns

ELECTRICAL SYSTEM 09V056000 2009-02-18 3,782 affected
Defect

FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.

Consequence

THIS CAN CAUSE ABRASION TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT AND POSSIBLY A FIRE.

Remedy

DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

EQUIPMENT 08V320000 2008-07-15 70,101 affected
Defect

FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND…

Consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Remedy

FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN…

STEERING 07V306000 2007-07-18 18,000 affected
Defect

FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE…

Consequence

INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.

Remedy

THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.

EQUIPMENT 07V019000 2007-01-26 93 affected
Defect

CERTAIN MOTOR HOMES FAIL TO COMPLY WITH SECTION 6.2.6, "MARKING OF ALTERNATIVE EXITS," AS REQUIRED BY THE ANSI/NFPA 1192 STANDARD ON RECREATIONAL VEHICLES. THE DINETTE ALTERNATE EXIT/EMERGENCY EGRESS WINDOW IS NOT IDENTIFIED BY AN EXIT LABEL AND RED EGRESS LATCHES. THIS WINDOW IS USED TO EXIT THE MOTOR HOME IN AN…

Consequence

IN THE EVENT OF A CRASH, A PASSENGER MAY NOT KNOW IMMEDIATELY WHERE THE EXIT/ EMERGENCY EGRESS WINDOW WOULD BE LOCATED, INCREASING THE RISK OF INJURY.

Remedy

DEALERS WILL INSPECT AND REPLACE THE EXISTING BLACK WINDOW LATCH WITH A RED EGRESS WINDOW LATCH AND APPLY THE "EXIT" LABEL TO THE DINETTE ALTERNATIVE EXIT/ EMERGENCY EGRESS WINDOW. THE RECALL BEGAN ON FEBRUARY 15, 2007. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.

Complaints by component

ELECTRICAL SYSTEM
1
1fires
ENGINE
1
1fires
SERVICE BRAKES, AIR:DRUM:DRUM
1
SERVICE BRAKES, AIR:DRUM:SHOES/LININGS
1
VISIBILITY
1
Total complaints5

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“The battery cables and wiring go through a firewall that is metal. The hole in the firewall does not contain any type of gasket or protective material and as a result the cables and wiring rub along the metal hole in the firewall. The cables and wires rub on the metal and cut through the…”

ELECTRICAL SYSTEM · reported 2016-05-27

“The battery cables and wiring go through a firewall that is metal. The hole in the firewall does not contain any type of gasket or protective material and as a result the cables and wiring rub along the metal hole in the firewall. The cables and wires rub on the metal and cut through the…”

ENGINE · reported 2016-05-27

“Tl* the contact owns a 2007 fleetwood excursion rv. The contact stated that he noticed that the driver side window had an abnormal accumulation of moisture and fog. The contact stated that the failure would become worse during rainy weather. The manufacturer advised the contact that they could not…”

VISIBILITY · reported 2011-01-02

“Defective motorcoach brakes 01/07/07 test drove new motor coach. During test drive it was difficult to slow the rv down. 01/09/07 rv taken to chassis manufacturer by dealer for brake noise. 01/11/07 received call from dealer that the chassis manufacturer had to replace a brake drum due to a recall…”

SERVICE BRAKES, AIR:DRUM:DRUM · reported 2007-01-13

“Defective motorcoach brakes 01/07/07 test drove new motor coach. During test drive it was difficult to slow the rv down. 01/09/07 rv taken to chassis manufacturer by dealer for brake noise. 01/11/07 received call from dealer that the chassis manufacturer had to replace a brake drum due to a recall…”

SERVICE BRAKES, AIR:DRUM:SHOES/LININGS · reported 2007-01-13
Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2007 Fleetwood Excursion as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.