The 2001 Fleetwood Expedition has 1 NHTSA recall campaign affecting an estimated 167,096 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 5 complaints with NHTSA, most often about the structure. Last updated July 5, 2026.
Recall campaigns
EQUIPMENT07V1200002007-03-19167,096 affected
Defect
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence
RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy
FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST…
Complaints by component
STRUCTURE:BODY:DOOR
1
SUSPENSION:FRONT:SHOCK ABSORBER
1
SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:LEAF
1
SUSPENSION:REAR
1
TIRES
1
Total complaints5
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Front entry door pulls open at top, and causes latch to be stressed and moved, requiring continuous adjustment. Doors pulls open enough at top that light can be seen outside, when raining water comes in, also causing extreemly loud wind/air noise inside vehicle. We feel this is a safety issue,…”
“I drive a 2001 fleetwood 36' expedition, it had about 21,00 miles at this time. On october 20, 2003 I had a r/f steering tire blowout s/e of st. Louis mo. Around 5pm. Had road service put on a used tire. Spent the night in sullivan mo. At a flying-j about 75 miles down the road. The morning of the…”
“While driving, vehicle will not stay in the center of the road, it will drift to the right or left, consumer states in order to initiate a turn, he has to turn the wheel, then after a second or two it starts to turn, consumer states if he does not wait for a few seconds he will then over steer and…”
“Experiencing occasional problems with the front suspension, sometime it unexpectedly buck in an up and downward motion while traveling on freeway, so driver is compelled to reduce their speed immediately and almost stop before being able to commence moving again safely. Dealer and myself agree…”
“Consumer states that the leaf spring broke causing the vehicle to drop low to the ground. Please provide any additional information. Ts”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2001 Fleetwood Expedition as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.