The 2001 Ford Explorer Sport Trac has 4 NHTSA recall campaigns affecting an estimated 5,738,585 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 229 complaints with NHTSA, most often about the power train. Last updated July 5, 2026.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence
THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL…
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
Consequence
THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
Remedy
DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
SEATS03V2810002003-08-051,552,880 affected
Defect
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH…
Consequence
THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
STRUCTURE00V3940002000-11-28137,700 affected
Defect
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES WITH STEEL HOODS AND CERTAIN PICKUP TRUCKS EQUIPPED WITH SHEET MOLDING COMPOUND HOODS. A WIRE FORMED HOOD STRIKER COULD BE SUSCEPTIBLE TO FATIGUE FRACTURES. IF THE HOOD STRIKER FRACTURES, THE HOOD COULD FLY OPEN WHILE THE VEHICLE IS BEING DRIVEN.
Consequence
A HOOD FLY-UP WHILE THE VEHICLE IS BEING OPERATED COULD RESULT IN REDUCED DRIVER VISIBILITY.
Remedy
DEALERS WILL REPLACE THE HOOD STRIKER.
Complaints by component
POWER TRAIN:AUTOMATIC TRANSMISSION
18
VEHICLE SPEED CONTROL
18
2crashes4fires1injuries
STRUCTURE:FRAME AND MEMBERS
13
1crashes
POWER TRAIN
10
1crashes
STRUCTURE:BODY
10
ELECTRICAL SYSTEM
9
1crashes
SUSPENSION
9
AIR BAGS
8
4crashes2fires3injuries
ENGINE AND ENGINE COOLING
8
1crashes1injuries
TIRES
7
1crashes1fires
Total complaints229
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“I was driving and the lights on the vehicle went out I thought it was the bulbs but no lights were working I adjusted steering wheel to look to see fuse box and all lights came back on there is an electrical short somewhere then I went to start the truck and it made a funny sound and then I lost…”
“I was driving and the lights on the vehicle went out I thought it was the bulbs but no lights were working I adjusted steering wheel to look to see fuse box and all lights came back on there is an electrical short somewhere then I went to start the truck and it made a funny sound and then I lost…”
“Transmission not working”
“Transmission not working”
“Car takes about 3 to 5 tries to start. I replaced gas pump, plugs, cables, temp sensor, still takes long to start.o/d off light started flashing, and now it has a rough gear change I believe from 2nd to 3rd”
“Car takes about 3 to 5 tries to start. I replaced gas pump, plugs, cables, temp sensor, still takes long to start.o/d off light started flashing, and now it has a rough gear change I believe from 2nd to 3rd”
“Car takes about 3 to 5 tries to start. I replaced gas pump, plugs, cables, temp sensor, still takes long to start.o/d off light started flashing, and now it has a rough gear change I believe from 2nd to 3rd”
“Vehicle running in park while driver gathered boxes to place in bed of truck. Drive train engaged sending driverless vehicle down road, across intersection and into brick wall. Witness to impact ran to vehicle thinking to check on driver. Upon opening door, noted no driver and stated shifter still…”
Defect investigations
InvestigationDP05005 Opened 2005-09-22 · closed 2006-01-04
SPARK PLUG EJECTION FROM CYLINDER HEAD
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR…
InvestigationDP05005 Opened 2005-09-22 · closed 2006-01-04
SPARK PLUG EJECTION FROM CYLINDER HEAD
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR…
InvestigationDP05005 Opened 2005-09-22 · closed 2006-01-04
SPARK PLUG EJECTION FROM CYLINDER HEAD
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR…
InvestigationPE03020 Opened 2003-05-21 · closed 2003-09-05
FRONT SEAT BACK RECLINER ATTACHMENT
BY LETTER DATED AUGUST 4, 2003, FORD NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V281) INVOLVING CERTAIN MODEL YEAR (MY) 1998-2001 FORD EXPLORER / MERCURY MOUNTAINEER 4-DOOR, MY 1998-2000 FORD EXPLORER 2-DOOR AND MY 2001-2002 FORD EXPLORER SPORT AND SPORT TRAC VEHICLES…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2001 Ford Explorer Sport Trac as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.