RecallRepo

2019 Ford F-150 Recalls

Recalls on record Updated July 2026

The 2019 Ford F-150 has 9 NHTSA recall campaigns affecting an estimated 1,823,432 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 1,638 complaints with NHTSA, most often about the power train. Last updated July 5, 2026.

Recall campaigns

EXTERIOR LIGHTING 26V373000 2026-06-09 91,198 affected
Defect

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such,…

Consequence

Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.

Remedy

Dealers will reprogram the body control module software, free of charge. Owner notification letters are expected to be mailed July 6. 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become…

BACK OVER PREVENTION 25V442000 2025-06-27 200,237 affected
Defect

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport,…

Consequence

A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy

Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

EQUIPMENT 24V852000 2024-11-08 27,678 affected
Defect

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor…

Consequence

Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy

Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

BACK OVER PREVENTION 22V252000 2022-04-14 21,904 affected
Defect

Ford Motor Company (Ford) is recalling certain 2019 F-150, Super Duty F-250, F-350, F-450, and F-550 vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety…

Consequence

A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.

Remedy

Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

EXTERIOR LIGHTING 20V097000 2020-02-21 166,196 affected
Defect

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps"…

Consequence

DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.

Remedy

Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.

ELECTRICAL SYSTEM 19V805000 2019-11-12 135,725 affected
Defect

Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering…

Consequence

Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.

Remedy

Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at…

SEATS 19V633000 2019-08-28 639,137 affected
Defect

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are…

Consequence

A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy

Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

ENGINE 19V278000 2019-04-08 131,068 affected
Defect

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's…

Consequence

A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

Remedy

Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at…

ENGINE 18V894000 2018-12-18 410,289 affected
Defect

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and…

Consequence

When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.

Remedy

Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.

Complaints by component

POWER TRAIN
664
4crashes3injuries
ENGINE
313
2fires1injuries
UNKNOWN OR OTHER
129
3crashes1fires5injuries
ELECTRICAL SYSTEM
93
1crashes5fires1injuries
ENGINE AND ENGINE COOLING
49
VEHICLE SPEED CONTROL
39
1crashes7injuries
STRUCTURE:BODY
27
1fires
BACK OVER PREVENTION
26
VISIBILITY/WIPER
25
AIR BAGS
24
7crashes15injuries
Total complaints1,638

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“10r80 transmission flares from 1st gear to 2nd gear along with downshifting from 4th gear to 1st gear when lightly accelerating.”

POWER TRAIN · reported 2026-06-29

“10r80 transmission failure erratic and harsh shifting transmission has been evaluated and rebuilt by independent service center. Noticed roughly 2 weeks of harsh shifting before the shifting became erratic.”

POWER TRAIN · reported 2026-06-25

“While driving at a low speed, when pressing the accelerator, the auto initially didn't respond, but then accelerated sharply after a delay (when the accelerator wasn't engaged). The transmission seemed to abrubtly shift up by 2 or 3 gears without warning requiring me to immediately depress the…”

POWER TRAIN · reported 2026-06-22

“While driving at a low speed, when pressing the accelerator, the auto initially didn't respond, but then accelerated sharply after a delay (when the accelerator wasn't engaged). The transmission seemed to abrubtly shift up by 2 or 3 gears without warning requiring me to immediately depress the…”

FUEL/PROPULSION SYSTEM · reported 2026-06-22

“Ford has a known issue with the 2019 f150 eco boost cam phaser rattling. They replaced once and it failed again. They now refuse to repair the fix that should have corrected the initial cam phaser issue. They continue to use faulty parts.”

POWER TRAIN · reported 2026-06-16

“Ford has a known issue with the 2019 f150 eco boost cam phaser rattling. They replaced once and it failed again. They now refuse to repair the fix that should have corrected the initial cam phaser issue. They continue to use faulty parts.”

UNKNOWN OR OTHER · reported 2026-06-16

“Ford has a known issue with the 2019 f150 eco boost cam phaser rattling. They replaced once and it failed again. They now refuse to repair the fix that should have corrected the initial cam phaser issue. They continue to use faulty parts.”

ENGINE · reported 2026-06-16

“Cam phaser rattle, infamous in many ford models. The 2019 eco boost is very known for this sound and issue, ford has offered temporary resolutions and assistance before but no permanent fix. This issue affects hundreds of thousand of ford models and is quoted at a $5,500 job by many dealers. Ford…”

ENGINE · reported 2026-06-16

Defect investigations

Investigation PE23001 Opened 2023-01-27 · closed 2024-02-08

Windshield trim molding Item detachment

On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2019 Ford F-150 as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.