RecallRepo

2007 GMC Envoy Recalls

Recalls on record Updated July 2026

The 2007 GMC Envoy has 5 NHTSA recall campaigns affecting an estimated 1,095,539 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 285 complaints with NHTSA, most often about the fuel system, gasoline. Last updated July 5, 2026.

Recall campaigns

VISIBILITY 15V599000 2015-09-24 9,932 affected
Defect

General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles. Fluid may enter into the driver's door master power window switch module, causing corrosion that could result in a short in the…

Consequence

The protective coating may not eliminate the risk that the circuit board could short and result in a fire, even while the vehicle is unattended.

Remedy

GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall…

EXTERIOR LIGHTING 15V519000 2015-08-14 429,170 affected
Defect

General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles. In the affected vehicles, the headlamp driver module…

Consequence

Headlamps that do not illuminate reduce the driver's ability to see the roadway and reduce the vehicle's visibility to oncoming vehicles, both of which increase the risk of a vehicle crash.

Remedy

GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14291.

VISIBILITY 14V404000 2014-07-02 184,611 affected
Defect

General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could…

Consequence

A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy

GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. An interim letter was mailed to owners in August 2014. A second owner letter will be mailed when parts are available.…

VISIBILITY 13V248000 2013-06-13 193,652 affected
Defect

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit…

Consequence

A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy

Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and…

VISIBILITY 12V406000 2012-08-16 278,174 affected
Defect

General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland,…

Consequence

A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy

Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors…

Complaints by component

FUEL SYSTEM, GASOLINE
60
ELECTRICAL SYSTEM
54
1crashes12fires1injuries
EXTERIOR LIGHTING
51
VISIBILITY/WIPER
15
6fires
FUEL/PROPULSION SYSTEM
12
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
9
4fires
ENGINE
8
AIR BAGS
7
5crashes3injuries
VISIBILITY
6
1injuries
ELECTRONIC STABILITY CONTROL (ESC)
5
Total complaints285

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“My switch on drivers door started on fire right after I purchased vehicle from third party. There was no warning I just smelled smoke while driving and pulled it out”

ELECTRICAL SYSTEM · reported 2026-05-02

“While stopped at a light engine turned itself off with every warning light went off. Glad this didn’t happen with I was driving at highway speed as I lost all systems.”

ENGINE · reported 2024-08-04

“The contact owns a 2007 gmc envoy. The contact stated that the power switch used to adjust the front driver seat had failed to operate as needed. The contact stated that the power switch had been replaced a total of three times within a two-month time frame. Recently, the power switch had failed…”

ELECTRICAL SYSTEM · reported 2023-09-01

“The contact owns a 2007 gmc envoy. The contact stated that the power switch used to adjust the front driver seat had failed to operate as needed. The contact stated that the power switch had been replaced a total of three times within a two-month time frame. Recently, the power switch had failed…”

VISIBILITY · reported 2023-09-01

“Headlights go out on there own and may come back on a few minutes later but right back out again. The vehicle had this as a recall but if it was repaired the repair is not working. The manufacturer is claiming the recall expired, obviously without them making contact to do the repair. Now they…”

EXTERIOR LIGHTING · reported 2023-06-01

“The contact owns a 2007 gmc envoy. The contact stated while driving approximately 60 mph and also at other speeds, the low beam headlights became inoperable. The contact was able to activate the high beam headlights to continue driving. The contact stated that the failure with the low beam…”

EXTERIOR LIGHTING:HEADLIGHTS · reported 2021-01-08

“The daytime running lights (drl) and the low beam headlights do not light even when the dashboard light switch is placed in the 'headlight' on position. Troubleshooting revealed that this failure was caused by the body control module (bcm) located beneath the rear seat. A digital logic signal from…”

ELECTRICAL SYSTEM · reported 2020-07-02

“The daytime running lights (drl) and the low beam headlights do not light even when the dashboard light switch is placed in the 'headlight' on position. Troubleshooting revealed that this failure was caused by the body control module (bcm) located beneath the rear seat. A digital logic signal from…”

EXTERIOR LIGHTING · reported 2020-07-02

Defect investigations

Investigation DP10001 Opened 2010-01-07 · closed 2011-05-23

Fuel Level Gauge System Failure

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents,…

Investigation DP10001 Opened 2010-01-07 · closed 2011-05-23

Fuel Level Gauge System Failure

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents,…

Investigation EA12004 Opened 2012-06-11 · closed 2013-06-21

Driver's Master Power Window Switch

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois,…

Investigation EA12004 Opened 2012-06-11 · closed 2013-06-21

Driver's Master Power Window Switch

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois,…

Investigation EA12004 Opened 2012-06-11 · closed 2013-06-21

Driver's Master Power Window Switch

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois,…

Investigation EA12004 Opened 2012-06-11 · closed 2013-06-21

Driver's Master Power Window Switch

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois,…

Investigation RQ17002 Opened 2017-04-24 · closed 2021-03-29

Loss of Headlights

The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2007 GMC Envoy as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.