The 2022 Ic Bus Cesb has 9 NHTSA recall campaigns affecting an estimated 80,186 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 6 complaints with NHTSA, most often about the engine. Last updated July 5, 2026.
Recall campaigns
STRUCTURE25V5800002025-09-04457 affected
Defect
International Motors, LLC (International) is recalling certain 2016-2026 IC Bus CESB and 2016-2021 RESB school buses. The underfloor reinforcement may not have been installed, compromising the structural integrity of the buses. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle…
Consequence
Reduced structural integrity may increase the risk of injury in a crash.
Remedy
Dealers will inspect and install a reinforcement channel as necessary, free of charge. Owner notification letters were mailed December 8, 2025. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 25514.
SERVICE BRAKES, HYDRAULIC25V5030002025-08-0616,553 affected
Defect
International Motors, LLC (International) is recalling certain 2016-2024 IC Bus CESB school buses. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.
Consequence
An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.
Remedy
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a silicone black jumper harness, free of charge. Owner notification letters were mailed December 15, 2025. Owners may contact International customer service at 1-800-448-7825. International's number…
SERVICE BRAKES, HYDRAULIC23V3980002023-06-0215,398 affected
Defect
Navistar, Inc. (Navistar) is recalling certain 2016 and 2018-2024 IC Bus CE school buses. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.
Consequence
An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.
Remedy
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch assembly and if necessary, the wire harness or fuse, free of charge. Owner notification letters were mailed September 29, 2023. Owners may contact Navistar's customer…
SERVICE BRAKES, AIR23V3710002023-05-2519,376 affected
Defect
Navistar, Inc. (Navistar) is recalling certain 2021-2024 IC Bus RE, 2022-2024 IC Bus CE, and IC Bus EV school buses. The anti-lock brake system (ABS) indicator light does not remain illuminated when a malfunction exists, and when the vehicle's ignition switch is on, and the vehicle is in motion. As such, these…
Consequence
An ABS indicator light that fails to remain illuminated will not alert the driver of an ABS malfunction, which could increase the risk of a crash.
Remedy
Dealers will update the software, free of charge. Owner notification letters are expected to be mailed July 24, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23516.
STRUCTURE23V0650002023-02-1012,507 affected
Defect
Navistar, Inc. (Navistar) is recalling certain 2022-2024 IC Bus CE, 2022-2023 IC CE SBus, IC RE, and 2023 EV school buses. The roof panel may have been manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221,…
Consequence
A school bus roof panel with insufficient joint strength may separate during a crash, increasing the risk of injury.
Remedy
Dealers will add additional fasteners to secure the joints, free of charge. Owner notification letters are expected to be mailed April 3, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23501.
STEERING22V4290002022-06-163,570 affected
Defect
Navistar, Inc. (Navistar) is recalling certain 2022-2023 IC CE School Buses. The steering gears may have been assembled incorrectly, which can cause the gear to fracture.
Consequence
A fractured steering gear can cause a loss of steering control, increasing the risk of a crash.
Remedy
Dealers will inspect the steering gear serial numbers, and replace the steering gears as necessary, free of charge. Interim owner notification letters were mailed August 15, 2022. Remedy parts are expected to become available in mid-October 2022. Owners may contact Navistar customer service at 1-800-448-7825. …
STEERING22V3670002022-05-234,970 affected
Defect
Navistar, Inc. is recalling certain 2022-2023 IC CE, IC RE, and 2023 IC EV school buses. The steering wheel retaining nut may have been tightened incorrectly, which can allow the steering wheel to loosen and detach from the steering column shaft.
Consequence
A loose or detached steering wheel increases the risk of a crash.
Remedy
Owners are advised not to drive their vehicles until the repair has been performed. Dealers will remove the steering wheel nut, apply thread locker, and reinstall the nut, free of charge. Owner notification letters were mailed on May 25, 2022. Owners may contact Navistar, Inc. customer service at (331) 332-1590. …
ENGINE AND ENGINE COOLING21V8370002021-10-257,322 affected
Defect
Navistar, Inc. (Navistar) is recalling certain 2020-2023 IC CE school buses. The engine control module (ECM) may set a fault code that results in an unexpected engine shut down.
Consequence
Unexpected engine shut down can increase the risk of a crash. Additionally, a disabled school bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.
Remedy
Dealers will reprogram the ECM, free of charge. Owner notification letters notifying owners of the safety risk were mailed January 18, 2022. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 21507.
STRUCTURE21V4500002021-06-1533 affected
Defect
Navistar, Inc. (Navistar) is recalling certain 2014 IC Bus CE, 2019 IC Bus CE, and 2022 IC Bus CE school buses. These buses are not equipped with enough emergency exits. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 217, "Bus Emergency Exits and Window…
Consequence
A lack of emergency exits can delay passengers from exiting the vehicle during an emergency, increasing their risk of injury.
Remedy
Dealers will install two additional emergency exit windows, free of charge. Owner notification letters were mailed on August 6, 2021. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 21506.
Complaints by component
ENGINE
4
ELECTRICAL SYSTEM
1
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
1
Total complaints6
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Engine exhaust head pipes before the catalytic converter melts down from excessive engine heat, creating a large exhaust hole. This is a school bus”
“The engine exhaust downpipe melted and cracked- creating a large exhaust pipe hole near the engine exhaust manifold. Releasing exhaust gases and potential flames. This is a school bus and it happens frequently with this model.”
“This is a school bus. Exhaust down pipe from exhaust manifold melted down and created a large hole for fumes and potential fire from excessive heat/fuel issue in engine.”
“This is a school bus. Exhaust down pipe from exhaust manifold melted down and created a large hole for fumes and potential fire from excessive heat/fuel issue in engine.”
“School bus- engine exhaust pipe from the exhaust manifold has melted from excessive heat in the system creating large hole for fumes and potential fire to escape. Exhaust is inadequate for the heat levels from the engine or engine performance is misprogrammed to create excessive heat/fuel.…”
“The contact called on behalf of the owner of a 2022 ic bus cesb. The contact works as the district mechanic for the chase county schools district. The contact stated that while driving the bus on a rural road, the alarm buzzer sensor on the emergency exit windows activated independently. Due to…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2022 Ic Bus Cesb as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.