2012 Thomas Built Saf-T-Liner Hdx Recalls

Recalls on record Updated July 2026

The 2012 Thomas Built Saf-T-Liner Hdx has 19 NHTSA recall campaigns affecting an estimated 162,117 vehicles. Recall repairs are always free at any authorized dealer. Last updated July 5, 2026.

Recall campaigns

STRUCTURE 22V762000 2022-10-12 17,613 affected
Defect

Daimler Trucks North America, LLC (DTNA) is recalling certain 2011-2023 Thomas Built EFX and HDX school buses. The exterior roof panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body…

Consequence

A school bus exterior roof panel with insufficient joint strength may separate during a crash, increasing the risk of injury.

Remedy

Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed June 2, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL957.

SEATS 22V634000 2022-08-19 7,561 affected
Defect

Daimler Trucks North America LLC (DTNA) is recalling certain 2011-2021 Thomas Built Saf-T Liner HDX school buses. The forward seat barriers may not provide sufficient protection to passengers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 222,…

Consequence

Occupants may collide with the front seat barriers with more force than intended during a crash, increasing the risk of injury.

Remedy

Dealers will install a spacer between the seat rail and the seat barrier, free of charge. Owner notification letters were mailed August 25, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL843. This recall replaces NHTSA recall 19V899.

STRUCTURE 20V252000 2020-05-05 7,979 affected
Defect

Daimler Trucks North America, LLC (DTNA) is recalling certain 2010-2020 Thomas Built Buses Saf-T-Liner HDX school buses. The lettering on the instruction label for the rear emergency exit window may be too small. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard…

Consequence

Small lettering may be difficult for occupants to read, delaying the reaction time to open the exit, increasing the risk of injury.

Remedy

DTNA will notify owners and mail a new label to attach to the exit window by first class mail, free of charge. DTNA issued owners an interim notification on June 17, 2020. The recall began September 10, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-849.

EQUIPMENT 18V083000 2018-01-30 606 affected
Defect

Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, FS65, and Minotour school buses, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from…

Consequence

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy

DTNA will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall is expected to begin March 30, 2018. Owners may contact DTNA customer service at 1-800-547-0712 or Kidde customer service at 1-855-262-3540 or online at www.kidde.com and click on "Product…

POWER TRAIN 16V326000 2016-05-19 43 affected
Defect

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2011-2017 Thomas Built Buses Saf-T-Liner HDX buses manufactured April 28, 2010, to April 15, 2016. The affected vehicles have a transmission retarder that may increase coolant system pressure high enough to cause hose fatigue and lead to…

Consequence

If the heater hose fails, hot coolant may leak inside the bus body increasing risk of injury to the passengers.

Remedy

DTNA will notify owners, and dealers will replace the heater hose, free of charge. DTNA distributed interim notifications to owners on July 6, 2016. The recall began on September 20, 2016. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-709.

POWER TRAIN 16V325000 2016-05-19 94 affected
Defect

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2011-2017 Thomas Built Buses Saf-T-Liner HDX school buses manufactured April 28, 2010, to April 15, 2016. The affected vehicles have a transmission retarder that may increase coolant system pressure high enough to cause hose fatigue and lead to…

Consequence

If the heater hose fails, hot coolant may leak inside the bus body increasing risk of injury to the passengers.

Remedy

DTNA will notify owners, and dealers will replace the heater hose, free of charge. An interim notice was mailed on July 6, 2016. The recall began on September 20, 2016. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-709.

EQUIPMENT ADAPTIVE/MOBILITY 15V564000 2015-09-04 52 affected
Defect

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2006-2015 Thomas Built Buses Saf-T-Liner HDX, Saf-T-Liner EF, Saf-T-Liner EFX, and Minotour DRW transit buses manufactured January 3, 2006, to August 1, 2014, and equipped with certain Ricon model S2005, S2010, S5005, S5010, S5505, S5510…

Consequence

If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy

DTNA will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on November 2, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for…

EQUIPMENT ADAPTIVE/MOBILITY 15V565000 2015-09-04 4,334 affected
Defect

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2006-2015 Thomas Built Buses FS-65, Saf-T-Liner C2, Saf-T-Liner EF, Saf-T-Liner EFX, Saf-T-Liner HDX, and Minotour DRW school buses manufactured January 3, 2006, to August 1, 2014, and equipped with certain Ricon model S2005, S2010, S5005, S5010,…

Consequence

If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy

DTNA will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began onNovember 2, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for…

STRUCTURE 15V432000 2015-07-07 103,038 affected
Defect

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2013 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER,…

Consequence

If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.

Remedy

DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. Daimler issued an interim notification to owners on August 25, 2015. The recall began on December 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall…

STRUCTURE 15V425000 2015-07-06 3,013 affected
Defect

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2004 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER,…

Consequence

If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.

Remedy

DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. An interim notice was mailed to owners on August 28, 2015. The recall began on December 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-685.

ENGINE AND ENGINE COOLING 15V344000 2015-06-03 746 affected
Defect

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2008-2015 Thomas Built Buses Saf-T-Liner HDX school buses manufactured May 25, 2008, to December 18, 2014, and equipped with certain Cummins Westport ISL G engines. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent…

Consequence

If engine oil comes into contact with a hot surface, there is an increased risk of a fire.

Remedy

Cummins will notify owners on behalf of DTNA, and dealers secure the ends of the 90-degree elbow. In addition, the electronic control module (ECM) will be reprogrammed with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of…

ENGINE AND ENGINE COOLING 15V343000 2015-06-03 3,200 affected
Defect

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2007-2016 Freightliner 114SD and M2 Business Class trucks, 2008-2009 Sterling LT8500 trucks and Thomas Built Bus Saf-T-Liner HDX transit buses equipped with certain Cummins Westport ISL G engines. Excessive engine crankcase pressures may cause…

Consequence

If engine oil comes into contact with a hot surface, there is an increased risk of a fire.

Remedy

Cummins will notify owners on behalf of DTNA, and dealers will secure the ends of the 90-degree elbow. In addition, the electronic control module (ECM) will be reprogrammed with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of…

ENGINE AND ENGINE COOLING 14V080000 2014-02-21 3,258 affected
Defect

Daimler Trucks North America LLC (Daimler) is recalling certain model year 2008-2015 Freightliner 114SD, Cascadia, M2 Business Class, Sterling LT8500, and Thomas Built Buses Saf-T-Liner HDX vehicles manufactured February 19, 2008, through February 11, 2014, and equipped with Cummins Westport Model ISL G and Cummins…

Consequence

The sensor malfunction could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.

Remedy

Cummins and Cummins Westport will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Customers may contact Daimler at 1-800-385-4357 or Cummins Inc. at 1-800-343-7357. Daimler's number for this recall is FL-660.

ENGINE AND ENGINE COOLING 14V079000 2014-02-21 727 affected
Defect

Daimler Trucks North America LLC (Daimler) is recalling certain model year 2009-2015 Thomas Built Saf-T-Liner HDX school buses manufactured February 25, 2008, through February 11, 2014, equipped with Cummins Westport Model ISL G engines. Condensation in the intake manifold may freeze during cold weather conditions…

Consequence

The sensor malfunction could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.

Remedy

Cummins and Cummins Westport will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Customers may contact Daimler at 1-800-385-4357 or Cummins Inc. at 1-800-343-7357. Daimler's number for this recall is FL-660.

SEATS 13V537000 2013-10-30 328 affected
Defect

Daimler Trucks North America (DTNA) is recalling certain model year 2012-2014 Thomas Built Saf-T-Liner HDX and Saf-T-Liner EFX school buses manufactured October 17, 2011, through July 2, 2013. A U-bolt intended to reinforce certain seat installations to the chassis may have been left out of the assembly process.

Consequence

In the event of a crash, the seats may not stay mounted to the chassis, increasing the risk of injury.

Remedy

DTNA will notify owners and dealers will install the U-bolts as required, free of charge. The recall began on December 13, 2013. Owners may contact DTNA at 1-503-745-5219. DTNA's recall number is FL-650.

STRUCTURE 12V297000 2012-06-28 163 affected
Defect

DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING CERTAIN MODEL YEAR 2010 THROUGH 2013 THOMAS BUILT SAF-T-LINER EF, SAF-T-LINER HDX, SAF-T-LINER C2, AND MINOTOUR NON SCHOOL BUSES MANUFACTURED FROM APRIL 5, 2011, THROUGH APRIL 23, 2012, EQUIPPED WITH SPECIALTY MANUFACTURING INC. (SMI) PROLO ROOF HATCHES. INCREASED…

Consequence

IN THE EVENT OF AN EMERGENCY, EGRESS OF THE BUS MAY BE HINDERED POSSIBLY RESULTING IN INJURY TO THE VEHICLE OCCUPANTS.

Remedy

THOMAS BUILT BUSES WILL NOTIFY OWNERS. SMI WILL PROVIDE SERVICE KITS ALONG WITH REPAIR INSTRUCTIONS TO DEALERS AND OWNERS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 22, 2012. OWNERS MAY CONTACT THOMAS BUILT BUSES AT 1-336-889-4871 OR SMI AT 1-800-951-7867.

STRUCTURE 12V296000 2012-06-28 1,312 affected
Defect

DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING CERTAIN MODEL YEAR 2010 THROUGH 2013 THOMAS BUILT SAF-T-LINER EF, SAF-T-LINER HDX, SAF-T-LINER C2, AND MINOTOUR SCHOOL BUSES MANUFACTURED FROM APRIL 5, 2011, THROUGH APRIL 23, 2012, EQUIPPED WITH SPECIALTY MANUFACTURING INC. (SMI) PROLO ROOF HATCHES. INCREASED…

Consequence

IN THE EVENT OF AN EMERGENCY, EGRESS OF THE BUS MAY BE HINDERED POSSIBLY RESULTING IN INJURY TO THE VEHICLE OCCUPANTS.

Remedy

THOMAS BUILT BUSES WILL NOTIFY OWNERS. SMI WILL PROVIDE SERVICE KITS ALONG WITH REPAIR INSTRUCTIONS TO DEALERS AND OWNERS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 22, 2012. OWNERS MAY CONTACT THOMAS BUILT BUSES AT 1-336-889-4871 OR SMI AT 1-800-951-7867.

ENGINE AND ENGINE COOLING 11V480000 2011-09-21 1,825 affected
Defect

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011- 2012 THOMAS BUILT SAF-T-LINER C2, SAF-T-LINER MVP-EF, AND SAF-T-LINER HDX SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 1, 2010, THROUGH DECEMBER 31, 2010, EQUIPPED WITH A CUMMINS ISX OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND…

Consequence

IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy

DAIMLER TRUCKS IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR DAIMLER TRUCKS AT 1-800-547-0712.

ENGINE AND ENGINE COOLING 11V474000 2011-09-15 6,225 affected
Defect

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011- 2012 BUSINESS CLASS M2 AND CORONADO TRUCKS MANUFACTURED FROM SEPTEMBER 1, 2010, THROUGH DECEMBER 31, 2010, EQUIPPED WITH A CUMMINS ISX OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET…

Consequence

IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy

DAIMLER TRUCKS IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR DAIMLER TRUCKS AT 1-800-547-0712.

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2012 Thomas Built Saf-T-Liner Hdx as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.