The 2022 Toyota Sienna Hybrid has 2 NHTSA recall campaigns affecting an estimated 625,912 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 21 complaints with NHTSA, most often about the air bags. Last updated July 5, 2026.
Recall campaigns
SEATS25V0860002025-02-13167,802 affected
Defect
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2021-2025 Sienna Hybrid vehicles. The bolts for the seatbacks on the third-row seat assemblies may not be tightened properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers…
Consequence
An improperly tightened seatback may not adequately restrain the occupant during a crash, increasing their risk of injury.
Remedy
Dealers will tighten the seat assembly bolts, free of charge. Owner notification letters were mailed April 1, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 25TA05.
ELECTRONIC STABILITY CONTROL (ESC)22V2390002022-04-13458,110 affected
Defect
Toyota Engineering & Manufacturing (Toyota) is recalling certain 2022 Lexus LX 600, Lexus NX 350h, Lexus NX 450h+, Toytoa RAV4 Hybrid, 2021-2022 Lexus LS 500h, Toyota Mirai, RAV4 PRIME, Sienna, Venza, and 2020-2022 Toyota Highlander Hybrid vehicles. The Skid Control ECU software may not turn on the Vehicle Stability…
Consequence
Driving with a deactivated stability control system increases the risk of a crash.
Remedy
Dealers will update the Skid Control ECU software, free of charge. Owner notification letters were mailed May 27, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 22TA03. Lexus' number for this recall is 22LA01.
Complaints by component
AIR BAGS
3
1crashes1injuries
SEATS
2
SERVICE BRAKES
2
ELECTRICAL SYSTEM
1
ELECTRICAL SYSTEM:ADAS:HUD:CAMERA/SENSOR
1
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
1
FUEL/PROPULSION SYSTEM
1
LANE DEPARTURE: WARNING
1
LATCHES/LOCKS/LINKAGES
1
1injuries
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
1
Total complaints21
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Stitching on the driver seat is tearing. Under normal wear. The vehicle is just out of the 3 year/36,000 warranty period. If the seat continues to degrade it will not be safe for future use as it worsens.”
“The car will occassionally lurch forward while braking. It's somewhat random but most often happens when going down a slight hill. My best guess is that there is an issue with the transition from regenerative braking to mechanical braking. It feels like the vehicle momentarily looses contact with…”
“Rear windshield shattered between 4/16/2026, 10:04 am and 4/16/2026, 6:43 pm without reason, no one near it to cause this broken windshield. I have simplisafe camera that showed no one was near the car. See attached pictures.”
“Rear windshield shattered between 4/16/2026, 10:04 am and 4/16/2026, 6:43 pm without reason, no one near it to cause this broken windshield. I have simplisafe camera that showed no one was near the car. See attached pictures.”
“I was pulling out onto a main road, pressed the accelerator and "not much" happened. The car accelerated to maybe 5 mph and no faster. Took my foot off the accelerator and pushed it to the floor. No response. It was like the vehicle only ran on ev mode and did not turn the engine on. In a second…”
“While braking, when the vehicle switches from regenerative braking to conventional, the vehical lurches or momentarily speeds up before stopping. All while brake petal is depressed.”
“The contact owns a 2022 toyota sienna hybrid. The contact stated that while his pregnant wife was driving and using the sunroof to allow air into the cabin, the sunroof glass suddenly shattered without impact. The dealer was not notified of the failure. The vehicle was not repaired. The…”
“The contact owns a 2022 toyota sienna hybrid. The contact stated that while driving 25 mph, the vehicle crashed into the rear of a stationary vehicle; however, the air bags failed to deploy. Additionally, the abs failed to activate as designed. The contact sustained a back injury upon impact;…”
Defect investigations
InvestigationDP22005 Opened 2023-01-27 · closed 2023-08-07
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2022 Toyota Sienna Hybrid as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.