The 2005 Volkswagen Jetta has 4 NHTSA recall campaigns affecting an estimated 1,400,867 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 354 complaints with NHTSA, most often about the power train. Last updated July 5, 2026.
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE…
Consequence
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW…
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT…
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L GASOLINE ENGINE, A FUEL SUPPLY LINE CLAMP LOCATED IN THE ENGINE COMPARTMENT MAY NOT BE POSITIONED PROPERLY AND COULD CAUSE A FUEL LEAK.
Consequence
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy
DEALERS WILL INSPECT THE POSITION OF THE ENGINE COMPARTMENT FUEL SUPPLY LINE CLAMP AND, IF NECESSARY, REPLACE THE CLAMP. THE RECALL BEGAN ON JULY 11, 2005. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy
DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Complaints by component
POWER TRAIN
43
ELECTRICAL SYSTEM
41
1crashes6fires1injuries
ENGINE
27
4fires2injuries
AIR BAGS
24
7crashes1fires6injuries
ENGINE AND ENGINE COOLING
19
POWER TRAIN:AUTOMATIC TRANSMISSION
18
1fires
POWER TRAIN:CLUTCH ASSEMBLY
14
ENGINE AND ENGINE COOLING:ENGINE
12
STRUCTURE:BODY
10
1crashes1fires
FUEL/PROPULSION SYSTEM
9
2fires
Total complaints354
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The drivers seat moves by it's self while driving. And apparently while it is parked which runs the battery dead”
“The transmissions are bad on these cars and when it's shifting gears it jerks and almost takes you off the road. I've had my car completely stop as I was driving and almost cause a wreck hurting myself in the process of not trying to kill someone walking because these cars are known to have this…”
“The transmissions are bad on these cars and when it's shifting gears it jerks and almost takes you off the road. I've had my car completely stop as I was driving and almost cause a wreck hurting myself in the process of not trying to kill someone walking because these cars are known to have this…”
“The contact owns a 2005 volkswagen jetta equipped with supermax tm-1 205/55r16 tires. The contact stated that while driving at various speeds the front driver tire began to have a vibrating sensation after a month of being placed on the vehicle within a few days the tire began to bounce becoming…”
“My daughter was in a serious accident, she hit a guard rail and lost control after spinning and hitting two more guard rails the never deployed. My daughter suffered a close head injury and facial lacerations. The car is a total lose, why didnt her air bags go off ? Is so she may have not…”
“My car while parked and the engine going will stop. Also when I'm on the freeway the epc light will turn on and feel like I have a loss of power and it feels like it is accelerating. My mechanic has no idea what is going on with my car.”
“My car while parked and the engine going will stop. Also when I'm on the freeway the epc light will turn on and feel like I have a loss of power and it feels like it is accelerating. My mechanic has no idea what is going on with my car.”
“My car while parked and the engine going will stop. Also when I'm on the freeway the epc light will turn on and feel like I have a loss of power and it feels like it is accelerating. My mechanic has no idea what is going on with my car.”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2005 Volkswagen Jetta as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.