The 1991 Chevrolet Camaro has 4 NHTSA recall campaigns affecting an estimated 273,878 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 110 complaints with NHTSA, most often about the fuel system, gasoline. Last updated July 5, 2026.
THE FUEL FILLER NECK SOLDER JOINT CAN DEVELOP CRACKS OR PIN HOLE LEAKS, WHICH DOES NOT COMPLY WITH FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE CRACKS AND HOLES CAN ALLOW FUEL VAPOR AND FUEL LEAKAGE.
CONSEQUENCE OF NON-COMPLIANCE: GASOLINE VAPORS AND FUEL LEAKS CAN RESULT IN A FIRE IF EXPOSED TO A SOURCE OF IGNITION.
DEALERS WILL INSPECT THE FUEL TANK ASSEMBLY AND REPLACE THOSE WHICH EXHIBIT THE CRACKS OR PIN HOLE LEAKS.
THE FRONT SEAT UPPER HINGE COVER SCREWS ARE TOO LONG, AND INTERFERE WITH THE SEAT BACK INERTIA LOCK. THIS PREVENTS THE SEAT BACK FROM LOCKING PROPERLY.
IN THE EVENT OF A SUDDEN STOP OR VEHICLE IMPACT, ANUNLOCKED SEAT BACK WOULD INCREASE THE RISK OF INJURY TO THE SEAT OCCUPANT.
REPLACE SCREWS SECURING UPPER HINGE TRIM COVER WITH CORRECT LENGTH SCREWS.
THE METAL LATCHPLATES MAY NOT ENGAGE THE BUCKLE ASSEMBLIES, CAUSING A "NO LATCH" CONDITION. MOVEMENT OF THE SEAT OCCUPANT IN THIS CONDITION COULD CAUSE LATCHPLATE RELEASE FROM THE BUCKLE.
UNBELTED OR INCORRECTLY BELTED SEAT OCCUPANTS ARESUBJECTED TO INCREASED RISK OF INJURY IN THE EVENT OF SUDDEN STOP OR ACCIDENT.
REPLACE THE RETRACTOR ASSEMBLY FOR THE SAFETY BELT (FRONT AND REAR IN COUPES AND FRONT ONLY IN CONVERTIBLES).
POOR BOND ADHESION BETWEEN THE WINDSHIELD GLASS AND THE MOUNTING, WHICH COULD ALLOW THE WINDSHIELD TO SEPARATE FROM THE VEHICLE DURING A COLLISION. THIS FAILS TO CONFORM WITH FMVSS 212.
IF WINDSHIELD SEPARATION OCCURS IN A COLLISION, ANUNBELTED OCCUPANT COULD BE EJECTED FROM THE VEHICLE, AND PERSONAL INJURY COULDOCCUR.
REMOVE ALL SEALER FROM WINDSHIELD AND MOUNTING; APPLY NEW BONDING AND SEALANT MATERIAL, AND REINSTALL WINDSHIELD.
Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.
“Fuel leaking onto ground when filling tank at a gas station. Found information about safety recall from 1994. Owned the car since 1996.”
“Tl* the contact owns a 1991 chevrolet camaro. The contact noticed an one inch crack on the fuel tank near the filler neck. The vehicle had not been diagnosed or repaired. The manufacturer was notified of the problem. The approximate failure mileage was 95,500.”
“5.0liter tbi vehicle stalled in traffic at idle only. I restarted and was able to exit freeway. Idle is good in park or neutral gear, idle is unsteady while in gear and stall occurs within seconds. Hi speed operation was good.after investigating possible causes, I determined main cause to be a…”
“5.0liter tbi vehicle stalled in traffic at idle only. I restarted and was able to exit freeway. Idle is good in park or neutral gear, idle is unsteady while in gear and stall occurs within seconds. Hi speed operation was good.after investigating possible causes, I determined main cause to be a…”
“Tl*the contact owns a 1991 chevrolet camaro. Whenever fuel was added to the vehicle there was a leak coming from the fuel tank. The dealer stated that the vehicle was too old for them to lookup the vin. The manufacturer was called and stated that the vin was not included in the recall;…”
“Tl*the contact owns a 1991 chevrolet camaro. The contact stated that while turning on the ignition, he smelled vapors and fumes emitting from the rear end of the vehicle. The contact found recall 94v077000 (fuel system, gasoline, storage, tank assembly, filler pipe and cap) which he believed was…”
“Hello, my camaro has had a gas leak from the gas tank/filler neck for several years now. About three years ago, I went to the chevrolet dealer and they recognized that it had a problem, but couldn't figure out how to fix it under the old recall that 'appears' to have expired. However, this is a…”
“Tl*- the contact owns a 1991 chevrolet camaro. The contact observed fuel leakage during fueling the gas tank .gasoline vapors and fuel leaks can result in a fire if exposed to a source of ignition. He contacted the manufacturer and was advised by a representative that the vehicle identification…”
AXLE SHAFT AND WHEEL LUG STUDS
There is no summary currently available
There is no summary currently available
COMPLAINTS ALLEGE THAT THE DRIVER-SIDE AIR BAG DEPLOYED WHILE DRIVING WITHOUT ANY VEHICLE IMPACT.
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1991 Chevrolet Camaro as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.