The 2003 Chevrolet Monte Carlo has 6 NHTSA recall campaigns affecting an estimated 10,219,966 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 204 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.
Recall campaigns
ENGINE AND ENGINE COOLING15V7010002015-10-261,003,556 affected
Defect
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and…
Consequence
Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy
The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engineÂ’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will…
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3,…
Consequence
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
ENGINE AND ENGINE COOLING09V1160002009-04-081,497,516 affected
Defect
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL…
Consequence
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy
DEALERS WILL REPLACE THE ENGINEÂ’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINEÂ’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438,…
EQUIPMENT03V2500002003-07-151,707,825 affected
Defect
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT…
AIR BAGS03V0510002003-02-14130 affected
Defect
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence
THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy
DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT…
AIR BAGS02V2220002002-08-09133,221 affected
Defect
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT…
Complaints by component
ELECTRICAL SYSTEM
44
3crashes3fires2injuries
ENGINE
32
9fires
ENGINE AND ENGINE COOLING
14
4fires
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
11
1crashes2injuries
AIR BAGS
8
3crashes3injuries
ENGINE AND ENGINE COOLING:ENGINE
6
1fires
SERVICE BRAKES, HYDRAULIC
6
1crashes1injuries
POWER TRAIN:AUTOMATIC TRANSMISSION
5
UNKNOWN OR OTHER
5
EXTERIOR LIGHTING
4
1crashes
Total complaints204
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“I keep rewriting this because for some reason it keeps timing out everytime I look for the video to attach. I brought the car to taska twice for underhood fire and ignition. No head gasket got fixed no spark plugs there is several issues water keeps getting in tires are rotted electrical problems…”
“I keep rewriting this because for some reason it keeps timing out everytime I look for the video to attach. I brought the car to taska twice for underhood fire and ignition. No head gasket got fixed no spark plugs there is several issues water keeps getting in tires are rotted electrical problems…”
“I keep rewriting this because for some reason it keeps timing out everytime I look for the video to attach. I brought the car to taska twice for underhood fire and ignition. No head gasket got fixed no spark plugs there is several issues water keeps getting in tires are rotted electrical problems…”
“The service manager told me the engine cover will be removed and not replaced. This downgrades the vehicle as the engine cover is part of the appearance element and gives a certain amount of protection to some components and wiring harnesses. It will soon be a classic and the engine cover is part…”
“Vehicle stalls when starting. While driving vehicle may shut off when moving on highway if you are not pushing on gas pedal. May be due to faulty egr or emissions component”
“Vehicle stalls when starting. While driving vehicle may shut off when moving on highway if you are not pushing on gas pedal. May be due to faulty egr or emissions component”
“Vehicle stalls when starting. While driving vehicle may shut off when moving on highway if you are not pushing on gas pedal. May be due to faulty egr or emissions component”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2003 Chevrolet Monte Carlo as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.