The 2003 Pontiac Grand Prix has 3 NHTSA recall campaigns affecting an estimated 2,708,614 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 137 complaints with NHTSA, most often about the engine. Last updated July 5, 2026.
Recall campaigns
ENGINE AND ENGINE COOLING15V7010002015-10-261,003,556 affected
Defect
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and…
Consequence
Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy
The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engineÂ’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will…
ENGINE AND ENGINE COOLING09V1160002009-04-081,497,516 affected
Defect
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL…
Consequence
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy
DEALERS WILL REPLACE THE ENGINEÂ’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINEÂ’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438,…
ENGINE AND ENGINE COOLING08V1180002008-03-12207,542 affected
Defect
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence
CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK…
Remedy
DEALERS WILL REPLACE THE ENGINEÂ’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINEÂ’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF…
Complaints by component
ENGINE
31
24fires1injuries
ELECTRICAL SYSTEM
14
1crashes3fires2injuries
ENGINE AND ENGINE COOLING
8
4fires
ENGINE AND ENGINE COOLING:ENGINE
5
1fires
EXTERIOR LIGHTING
4
TIRES
4
1crashes2injuries
ELECTRICAL SYSTEM:IGNITION
3
FUEL SYSTEM, GASOLINE
3
1fires
SERVICE BRAKES
3
STRUCTURE
3
Total complaints137
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The vehicle overheated and caught fire.”
“Hi it happend about 2 weeks ago I stop to get gas in the car an when I left I started noticeing the car was running kinda of weird I get to were I was going an turn the car off for about 10mins an then tried to start it bck up an it acted like it wldnt I had to get a jump to get it barely started…”
“Hi it happend about 2 weeks ago I stop to get gas in the car an when I left I started noticeing the car was running kinda of weird I get to were I was going an turn the car off for about 10mins an then tried to start it bck up an it acted like it wldnt I had to get a jump to get it barely started…”
“Tl* the contact owned a 2003 pontiac grand prix. While the contact's vehicle was parked at a fuel station, she was informed that smoke was coming from the vehicle. The contact moved the vehicle away from the fuel pumps. There were no warning indicators illuminated. The contact stated that someone…”
“Car was parked. I heard a loud "whoosh" noise and then flames came from under my hood. I quickly cut my battery cables to hopefully save my car. I received a recall notice but when I call the dealership for repair they tell me to contact gm motors since the damage (recall) already happened. Gm…”
“Tl* the contact owns a 2003 pontiac grand prix. Upon entering the parked vehicle, the contact noticed that the instrument panel was on fire. The contact did not see the fire because it extinguished itself. The fire and police departments were not notified. The vehicle was not taken to a dealer or…”
“Recall on engine pulled into driveway open hood car with smoking then it united fire there is oil on the drip pan but that's been going on for years never got a recall note in the mail”
“Recall on engine pulled into driveway open hood car with smoking then it united fire there is oil on the drip pan but that's been going on for years never got a recall note in the mail”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2003 Pontiac Grand Prix as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.