RecallRepo

2002 Pontiac Grand Prix Recalls

Recalls on record Updated July 2026

The 2002 Pontiac Grand Prix has 3 NHTSA recall campaigns affecting an estimated 2,708,614 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 410 complaints with NHTSA, most often about the engine. Last updated July 5, 2026.

Recall campaigns

ENGINE AND ENGINE COOLING 15V701000 2015-10-26 1,003,556 affected
Defect

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and…

Consequence

Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy

The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engineÂ’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will…

ENGINE AND ENGINE COOLING 09V116000 2009-04-08 1,497,516 affected
Defect

GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL…

Consequence

IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Remedy

DEALERS WILL REPLACE THE ENGINEÂ’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINEÂ’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438,…

ENGINE AND ENGINE COOLING 08V118000 2008-03-12 207,542 affected
Defect

GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.

Consequence

CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK…

Remedy

DEALERS WILL REPLACE THE ENGINEÂ’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINEÂ’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF…

Complaints by component

ENGINE
86
52fires1injuries
ENGINE AND ENGINE COOLING
39
1crashes21fires1injuries
ELECTRICAL SYSTEM
37
2crashes7fires2injuries
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
14
FUEL/PROPULSION SYSTEM
12
5fires1injuries
EXTERIOR LIGHTING
11
1crashes
SERVICE BRAKES, HYDRAULIC
11
1crashes1fires1injuries
STEERING
10
AIR BAGS
9
7crashes10injuries
UNKNOWN OR OTHER
9
1crashes1fires
Total complaints410

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“The contact owns a 2002 pontiac grand prix. The contact received notification of nhtsa campaign number: 15v701000 (engine and engine cooling). The vehicle was taken to the dealer, where the contact was informed that the vehicle could not be serviced because it was an older vehicle, and the dealer…”

ENGINE AND ENGINE COOLING · reported 2025-10-09

“On may 27th 2023 just three days ago I went to start my car but it would not start, I tried two times then I smelled gas so I let it sit over night then the next day my friend went out to start it for me and it made a loud bang and the intake manifold exploded causing a fire and debris went…”

FUEL/PROPULSION SYSTEM · reported 2023-05-27

“I had just drove about 30 miles home and when I arrived my engine was was smoking a little more than was usual because of oil burn off. So I popped the hood and a fire started in the back of the engine where I was having problems previously with the power steering pump. Obviously when I opened the…”

ENGINE · reported 2022-08-30

“I was driving a red 2002 pontiac. While sitting at a stop sign and the driver of a 2012 ford fiesta was going 55-60 mph and ran in the back of my vehicle.”

AIR BAGS · reported 2021-11-30

“The night of the incident I was driving to my brother's house when I pulled over lifted the hood it burst into flames”

FUEL/PROPULSION SYSTEM · reported 2021-11-24

“The night of the incident I was driving to my brother's house when I pulled over lifted the hood it burst into flames”

ENGINE · reported 2021-11-24

“The night of the incident I was driving to my brother's house when I pulled over lifted the hood it burst into flames”

ELECTRICAL SYSTEM · reported 2021-11-24

“Tl* the contact owns a 2002 pontiac grad prix. The contact stated that after the vehicle was serviced by an independent mechanic for a tune-up, oil change and no failure codes found. The contact stated after retrieving the vehicle from the mechanic, she was driving approximately 45 mph when smoke…”

ENGINE AND ENGINE COOLING · reported 2020-02-23

Defect investigations

Investigation EA02030 Opened 2002-10-22 · closed 2004-03-09

ENGINE COMPARTMENT FIRES

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME…

Investigation EA02030 Opened 2002-10-22 · closed 2004-03-09

ENGINE COMPARTMENT FIRES

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME…

Investigation EA02030 Opened 2002-10-22 · closed 2004-03-09

ENGINE COMPARTMENT FIRES

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME…

Investigation EA07008 Opened 2007-06-12 · closed 2008-05-01

ENGINE COMPARTMENT FIRE

BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67…

Investigation EA07008 Opened 2007-06-12 · closed 2008-05-01

ENGINE COMPARTMENT FIRE

BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67…

Investigation PE07001 Opened 2007-01-17 · closed 2007-04-30

LOSS OF BRAKE LAMP ILLUMINATION

THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA…

Investigation PE07001 Opened 2007-01-17 · closed 2007-04-30

LOSS OF BRAKE LAMP ILLUMINATION

THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA…

Investigation PE07006 Opened 2007-01-29 · closed 2007-06-12

ENGINE COMPARTMENT FIRE

ON JANUARY 29, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED NON-CRASH FIRES ORIGINATING IN THE ENGINE COMPARTMENT IN CERTAIN MODEL YEAR (MY) 1999-2002 PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE ?L67? SUPERCHARGED VERSION OF THE GENERAL MOTORS (GM) 3800…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2002 Pontiac Grand Prix as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.