RecallRepo

2023 Chevrolet Tahoe Recalls

Recalls on record Updated July 2026

The 2023 Chevrolet Tahoe has 5 NHTSA recall campaigns affecting an estimated 1,787,551 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 286 complaints with NHTSA, most often about the engine. Last updated July 5, 2026.

Recall campaigns

FUEL SYSTEM, DIESEL 25V619000 2025-09-18 12 affected
Defect

General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.

Consequence

A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.

Remedy

Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number…

ENGINE AND ENGINE COOLING 25V274000 2025-04-24 597,571 affected
Defect

General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can…

Consequence

Engine failure increases the risk of a crash.

Remedy

Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed…

SERVICE BRAKES, HYDRAULIC 24V674000 2024-09-12 449,671 affected
Defect

General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As…

Consequence

Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

Remedy

The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac…

SUSPENSION 23V642000 2023-09-20 189 affected
Defect

General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.

Consequence

A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.

Remedy

Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this…

EXTERIOR LIGHTING 22V903000 2022-12-08 740,108 affected
Defect

General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights…

Consequence

DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

Remedy

The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at…

Complaints by component

ENGINE
102
1injuries
POWER TRAIN
37
ELECTRICAL SYSTEM
35
2crashes1injuries
SERVICE BRAKES
20
1crashes
ENGINE AND ENGINE COOLING
16
UNKNOWN OR OTHER
14
FORWARD COLLISION AVOIDANCE: WARNINGS
7
1crashes
FUEL/PROPULSION SYSTEM
7
VISIBILITY/WIPER
7
AIR BAGS
6
1crashes
Total complaints286

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“The contact owns a 2023 chevrolet tahoe. The contact stated that while driving at 40 mph, a warning message advising to reduce acceleration was displayed, the check engine warning light illuminated, and the vehicle stalled. The contact was able to pull over safely. The contact stated that the…”

ENGINE AND ENGINE COOLING · reported 2026-06-09

“The contact owns a 2023 chevrolet tahoe. The contact stated that while driving at 40 mph, a warning message advising to reduce acceleration was displayed, the check engine warning light illuminated, and the vehicle stalled. The contact was able to pull over safely. The contact stated that the…”

FUEL SYSTEM, GASOLINE · reported 2026-06-09

“The contact owns a 2023 chevrolet tahoe. The contact stated that while driving at 40 mph, a warning message advising to reduce acceleration was displayed, the check engine warning light illuminated, and the vehicle stalled. The contact was able to pull over safely. The contact stated that the…”

POWER TRAIN · reported 2026-06-09

“It has not been inspected yet but will call the dealer tomorrow morning since I just this vehicle on friday”

SERVICE BRAKES · reported 2026-06-07

“While traveling at 55mph yesterday, I experienced a full engine failure which shut the car off fully while traveling on a single lane double yellow road. I was able to coast to a secure location. The car will not start or go into neutral. There were no warning lights that occurred at any time…”

ENGINE · reported 2026-05-25

“Total engine failure.”

ENGINE · reported 2026-05-20

“Following a gm-initiated over-the-air (ota) software update on may 18, 2026, my vehicle's windshield wipers became permanently inoperable — stuck in the "on" position with no ability to turn them off. This is not a gradual mechanical failure or wear-and-tear issue. The malfunction began…”

VISIBILITY/WIPER · reported 2026-05-18

“Engine stopped while driving 70 mph down the highway and the car shifted into neutral. Had to cost to side of the road. Took car into dealership and even though the car was certified safe drive and the engine had no issues 5 months ago, I was told the engine was now locking up. The engine failed…”

POWER TRAIN · reported 2026-04-29

Defect investigations

Investigation EA25007 Opened 2025-10-23 · open

Loss of motive power due to engine failure

The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado…

Investigation EA25007 Opened 2025-10-23 · open

Loss of motive power due to engine failure

The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado…

Investigation PE25001 Opened 2025-01-16 · closed 2025-10-23

Loss of motive power due to engine failure

On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing…

Investigation PE25001 Opened 2025-01-16 · closed 2025-10-23

Loss of motive power due to engine failure

On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing…

Investigation RQ26001 Opened 2026-01-16 · open

Loss of motive power due to engine failure post recall remedy

The Office of Defects Investigation (ODI) has received 36 Vehicle Owner Questionnaires (VOQs) alleging engine failure in vehicles subject to Recall 25V274. In each VOQ, the engine had the recall remedy completed prior to the reported failure incident. Recall 25V-274 addresses vehicles equipped with a L87 6.2L V8 gas…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2023 Chevrolet Tahoe as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.