RecallRepo

2002 GMC Yukon Recalls

Recalls on record Updated July 2026

The 2002 GMC Yukon has 3 NHTSA recall campaigns affecting an estimated 1,916,296 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 187 complaints with NHTSA, most often about the service brakes. Last updated July 5, 2026.

Recall campaigns

SERVICE BRAKES, HYDRAULIC 05V379000 2005-08-29 1,353,718 affected
Defect

CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND,…

Consequence

THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN…

STRUCTURE 03V094000 2003-03-07 3,674 affected
Defect

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE…

Consequence

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Remedy

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

SEATS 02V253000 2002-09-17 558,904 affected
Defect

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH REARWARD FOLDING HEAD RESTRAINTS ON THE SECOND ROW SEATS, TWO POTENTIAL PINCH POINTS EXIST ON EACH OF THE FOLDING HEAD RESTRAINTS WHEN THE RESTRAINTS ARE FOLDED REARWARD AS THE SEATBACK IS FOLDED DOWN.

Consequence

IF A PERSON WERE TO INSERT THEIR FINGER(S) INTO THE PINCH POINT WHEN THE HEAD RESTRAINT FOLDS, IT COULD TRAP AND PINCH THE FINGER(S) CAUSING INJURY.

Remedy

DEALERS WILL INSTALL PROTECTIVE COVERS OVER THE PINCH POINTS. OWNER NOTIFICATION BEGAN NOVEMBER 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT…

Complaints by component

SERVICE BRAKES
37
3crashes
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
21
SERVICE BRAKES, HYDRAULIC
14
2crashes1injuries
ELECTRICAL SYSTEM
8
2fires
AIR BAGS
7
7crashes6injuries
PARKING BRAKE
5
STEERING
5
TIRES
5
ENGINE AND ENGINE COOLING
4
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
4
Total complaints187

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“No warning while exiting, I was able to hit the brakes. Then, when I reached for the brakes again, it didn’t break. There was no signals on the car. The car is total damage air bags came out.”

SERVICE BRAKES · reported 2025-08-09

“Tl* the contact owns a 2002 gmc yukon. The contact stated after he drove the vehicle at a very low speed, the vehicle unexpectedly experienced unwanted antilock brake system (abs) activation. The contact stated he was forced to drive at a higher speed in order to avoid this issue. The contact…”

SERVICE BRAKES · reported 2020-06-08

“Brakes went. Bought a ct car in sc. Luckily driving 5pmh when they went. Waiting at the shop now to get fixed. Spent the night in my car as I was moving to ct”

SERVICE BRAKES · reported 2020-01-06

“My vehicle is being tampered with, intentionally repairs improperly preformed steering wheels engine northstar all. Affected.”

STEERING · reported 2019-09-29

“My vehicle is being tampered with, intentionally repairs improperly preformed steering wheels engine northstar all. Affected.”

WHEELS · reported 2019-09-29

“My vehicle is being tampered with, intentionally repairs improperly preformed steering wheels engine northstar all. Affected.”

UNKNOWN OR OTHER · reported 2019-09-29

“Vehicle was involved in a roll over one frontal car accident. Not for sure of the speed but it was oover 50 miles an hour. I hit brake going around the curve and fliiped over over five times and not yet the airbag didnt deploy. Forced cause of the seat bealt to strecch and lock in place. Police…”

AIR BAGS · reported 2019-08-01

“I was driving the car and then I came to my stop when I notice my car was trying to start again while it was in park and I notice that my car then started smoking while trying to start on it own after that happen my car has never started again please help”

ELECTRICAL SYSTEM · reported 2019-04-10

Defect investigations

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation EA02015 Opened 2002-08-01 · closed 2004-01-12

THROTTLE STICKING CLOSED

THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN…

Investigation PE05020 Opened 2005-04-28 · closed 2005-09-13

UNWANTED LOW-SPEED ABS ACTIVATION

IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES…

Investigation PE05020 Opened 2005-04-28 · closed 2005-09-13

UNWANTED LOW-SPEED ABS ACTIVATION

IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES…

Investigation PE10010 Opened 2010-03-30 · closed 2011-01-05

Brake line corrosion failure

The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010…

Investigation PE10010 Opened 2010-03-30 · closed 2011-01-05

Brake line corrosion failure

The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2002 GMC Yukon as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.