RecallRepo

2003 GMC Yukon Recalls

Recalls on record Updated July 2026

The 2003 GMC Yukon has 4 NHTSA recall campaigns affecting an estimated 1,432,480 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 251 complaints with NHTSA, most often about the service brakes. Last updated July 5, 2026.

Recall campaigns

SEAT BELTS 05V163000 2005-04-22 1,359,824 affected
Defect

ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT,…

Consequence

A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.

Remedy

DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT…

SERVICE BRAKES, HYDRAULIC 04V045000 2004-02-04 68,875 affected
Defect

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

Consequence

CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.

Remedy

DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.

STRUCTURE 03V094000 2003-03-07 3,674 affected
Defect

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE…

Consequence

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Remedy

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

STRUCTURE 03V037000 2003-02-06 107 affected
Defect

CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.

Consequence

AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.

Remedy

DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE…

Complaints by component

SERVICE BRAKES
40
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
28
ELECTRICAL SYSTEM
25
VEHICLE SPEED CONTROL
13
1crashes
ENGINE
12
SERVICE BRAKES, HYDRAULIC
12
1crashes
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
7
ENGINE AND ENGINE COOLING
6
1crashes
STEERING
6
AIR BAGS
5
2crashes6injuries
Total complaints251

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“My 03 yukon denali is experiencing all of the same things that the recall on the 2021 yukon is experiencing. What do I do? The recall notice I am referring to is n252494000”

ENGINE · reported 2023-02-23

“My 03 yukon denali is experiencing all of the same things that the recall on the 2021 yukon is experiencing. What do I do? The recall notice I am referring to is n252494000”

FUEL/PROPULSION SYSTEM · reported 2023-02-23

“The contact owns a 2003 gmc yukon. The contact stated that while driving at various speed, the vehicle would stall as the battery warning light appeared on the instrument panel. The contact also stated that the vehicle would shake upon depression of the brake pedal without warning. The vehicle was…”

POWER TRAIN · reported 2022-07-01

“The contact owns a 2003 gmc yukon. The contact stated that upon purchasing the vehicle from a towing company, the vehicle would not start. The battery was instantly replaced. The contact stated that the vehicle would wobble and shut off inadvertently while driving. The vehicle was taken to an…”

ENGINE · reported 2022-03-25

“The contact owns a 2003 gmc yukon. The contact stated that upon purchasing the vehicle from a towing company, the vehicle would not start. The battery was instantly replaced. The contact stated that the vehicle would wobble and shut off inadvertently while driving. The vehicle was taken to an…”

ELECTRICAL SYSTEM · reported 2022-03-25

“The contact owns a 2003 gmc yukon. The contact stated that upon purchasing the vehicle from a towing company, the vehicle would not start. The battery was instantly replaced. The contact stated that the vehicle would wobble and shut off inadvertently while driving. The vehicle was taken to an…”

SUSPENSION · reported 2022-03-25

“When I turn out of a parking spot it clicks and pops replaced ball joints shocks tie rods everything it won't go away and it does it when I pull into a parking spot”

SUSPENSION · reported 2020-04-07

“Car looses power and goes into reduced engine power. Unable to drive over 2mph. Happens at random times, in all modes of travel, uphill, downhill, from a stop and acceleration. The worst was when it happened going 55mph on a highway. Two separate mechanics have been unable to pinpoint the problem…”

ENGINE · reported 2019-10-16

Defect investigations

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation DP05009 Opened 2005-12-20 · closed 2006-05-31

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.

Investigation EA04011 Opened 2004-04-09 · closed 2005-05-10

PARKING BRAKE FAILURE

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL…

Investigation EA04011 Opened 2004-04-09 · closed 2005-05-10

PARKING BRAKE FAILURE

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL…

Investigation EA04011 Opened 2004-04-09 · closed 2005-05-10

PARKING BRAKE FAILURE

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL…

Investigation EA04011 Opened 2004-04-09 · closed 2005-05-10

PARKING BRAKE FAILURE

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL…

Investigation PE10010 Opened 2010-03-30 · closed 2011-01-05

Brake line corrosion failure

The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010…

Investigation PE10010 Opened 2010-03-30 · closed 2011-01-05

Brake line corrosion failure

The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2003 GMC Yukon as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.