RecallRepo

1996 Plymouth Grand Voyager Recalls

Recalls on record Updated July 2026

The 1996 Plymouth Grand Voyager has 9 NHTSA recall campaigns affecting an estimated 3,861,190 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 922 complaints with NHTSA, most often about the power train. Last updated July 5, 2026.

Recall campaigns

AIR BAGS 02V293000 2002-11-07 1,500,521 affected
Defect

ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.

Consequence

THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.

Remedy

DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. …

FUEL SYSTEM, GASOLINE 00V268000 2000-09-13 1,163,000 affected
Defect

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

Consequence

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy

DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE…

FUEL SYSTEM, GASOLINE 99V216000 1999-08-09 635,469 affected
Defect

VEHICLE DESCRIPTION: MINIVANS. FUEL CAN LEAK FROM THE FUEL TANK AT THE INTERFACE OF THE FUEL PUMP MODULE ATTACHMENT.

Consequence

IF A FUEL LEAK OCCURS IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy

DEALERS WILL REPLACE THE FUEL PUMP MODULE ATTACHING NUT WITH A NUT THAT INCLUDES TIGHTER DESIGN TOLERANCES. THE SEALING O-RING WILL ALSO BE REPLACED.

CHILD SEAT 98V185000 1998-08-06 157,000 affected
Defect

VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.

Consequence

THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.

Remedy

DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL…

SEAT BELTS 96V136000 1996-07-18 200 affected
Defect

THE BOLTS WHICH SECURE THE INTEGRATED CHILD SEAT MODULES TO THE SEAT FRAME CAN BREAK.

Consequence

IN THE EVENT OF A VEHICLE ACCIDENT, THE CHILD SEAT MAY NOT PROVIDE ADEQUATE PROTECTION TO THE OCCUPANT.

Remedy

DEALERS WILL REPLACE THE INTEGRATED CHILD SEAT MODULE BOLTS.

FUEL SYSTEM, GASOLINE 96V002000 1996-01-16 265,000 affected
Defect

A STATIC ELECTRIC CHARGE CAN BUILD UP ON THE UNGROUNDED METAL SECTION OF THE FUEL FILLER TUBE.

Consequence

THIS CONDITION COULD CAUSE A SPARK TO OCCUR WHEN FUELING THE VEHICLE AND POSSIBLY IGNITE THE FUEL VAPORS.

Remedy

DEALERS WILL INSTALL A GROUND STRAP FOR THE FUEL FILLER TUBE.

ENGINE AND ENGINE COOLING 96V006000 1996-01-11 40,000 affected
Defect

IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.

Consequence

INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.

Remedy

DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.

FUEL SYSTEM, GASOLINE 95V236000 1995-12-08 80,000 affected
Defect

THE FUEL TANK ROLLOVER VALVE CAN ALLOW FUEL TO PASS INTO THE VAPOR CANISTER RESULTING IN THE POTENTIAL FOR FUEL LEAKAGE.

Consequence

FUEL LEAKAGE INCREASES THE POTENTIAL FOR A VEHICLE FIRE.

Remedy

DEALERS WILL REPLACE THE FUEL TANK FILLER TUBE WITH A FILLER TUBE THAT HAS AN ADDITIONAL ROLLOVER VALVE. THE ASSOCIATED ROLLOVER VALVE VAPOR HOSES WILL BE REROUTED.

SEATS 95V225000 1995-11-28 20,000 affected
Defect

THE BOLTS WHICH SECURE THE REAR BENCH SEATS TO THE SEAT RISERS MAY BE EMBRITTLED AND FRACTURE.

Consequence

IN CASE OF AN ACCIDENT, THE BOLT MAY FAIL AND CAN CAUSE THE SEAT TO BREAK AWAY FROM THE SEAT RISERS, WHICH INCREASES THE POTENTIALOF INJURY TO ITS OCCUPANTS.

Remedy

DEALERS WILL REPLACE THE REAR BENCH SEAT TO RISER BOLTS.

Complaints by component

POWER TRAIN:AUTOMATIC TRANSMISSION
80
AIR BAGS
76
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
60
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
55
22fires
ELECTRICAL SYSTEM:HORN
43
STRUCTURE:BODY:DOOR
32
VEHICLE SPEED CONTROL
32
VISIBILITY:WINDSHIELD WIPER/WASHER
30
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
27
2crashes1injuries1deaths
ELECTRICAL SYSTEM
19
4fires
Total complaints922

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Affected component: body control module the bcm controls the following: wipers, fuel pump, vehicle power and much more. During a rainy day in oregon ciry oregon, the bcm failed. The car was moving into a parking lot at less than 20 mph. In the parking lot was a police vehicle. When the bcm failed,…”

SERVICE BRAKES · reported 2016-12-17

“Affected component: body control module the bcm controls the following: wipers, fuel pump, vehicle power and much more. During a rainy day in oregon ciry oregon, the bcm failed. The car was moving into a parking lot at less than 20 mph. In the parking lot was a police vehicle. When the bcm failed,…”

FUEL/PROPULSION SYSTEM · reported 2016-12-17

“Affected component: body control module the bcm controls the following: wipers, fuel pump, vehicle power and much more. During a rainy day in oregon ciry oregon, the bcm failed. The car was moving into a parking lot at less than 20 mph. In the parking lot was a police vehicle. When the bcm failed,…”

VISIBILITY/WIPER · reported 2016-12-17

“While driving at any speed (around 65 miles) my vehicle suddenly shutdown without warning due to fuel pump. I haven't fixed yet. And it has a electrical problems too. *tr”

FUEL/PROPULSION SYSTEM · reported 2014-10-15

“Engine would start and run a few seconds and then go dead. Engine would restart and run very rough for a few seconds and continue to go dead. Eventually engine would not start. Checked power at coil and there would be power for a second when switch was turned on and then auto shutdown relay clicks…”

ENGINE · reported 2014-05-08

“Tl*the contact owned a 1996 plymouth grand voyager. While driving in reverse approximately 1 mph he smelled an odor of gasoline and the vehicle engulfed into flames. The fire began underneath the hood of the vehicle. The fire department extinguished the flames. The vehicle was destroyed and towed…”

FUEL SYSTEM, GASOLINE · reported 2010-11-22

“1996 plymouth grand voyager had an engine fire due to a leaking fuel rail - investigation revealed the rail was under an open recall that was never fixed and I never received notice of it. *tr”

FUEL SYSTEM, GASOLINE · reported 2009-07-09

“My wife was driving my 1996 plymouth grand voyager and the left cv shaft support bearing broke off the differential. *tr”

POWER TRAIN:AUTOMATIC TRANSMISSION · reported 2008-09-07

Defect investigations

Investigation EA01007 Opened 2001-02-21 · closed 2002-11-22

AIR BAG CLOCKSPRING

There is no summary currently available

Investigation EA97002 Opened 1997-01-31 · closed 1998-02-10

FUEL TANK LEAKS

THIS ENGINEERING ANALYSIS WAS OPENED ON JANUARY 31, 1997 BASED ON INFORMATION GATHERED DURING PRELIMINARY EVALUATION (PE), PE96-051. THE PE WAS OPENED ON AUGUST 19, 1996, TO INVESTIGATE ALLEGATIONS OF FUEL LEAKAGE FROM THE AREA WHERE THE FUEL PUMP/SENDING UNIT JOINS THE FUEL TANK.FOR BREVIDY, THIS AREA WILL BE…

Investigation EA97003 Opened 1997-01-31 · closed 1998-08-19

INTEGRATED CHILD SEAT BELT LOCKUP

THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.

Investigation EA97003 Opened 1997-01-31 · closed 1998-08-19

INTEGRATED CHILD SEAT BELT LOCKUP

THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.

Investigation EA99013 Opened 1999-06-11 · closed 2001-08-10

POST COLLISION FUEL SYSTEM

Investigation PE00032 Opened 2000-08-08 · closed 2001-02-21

AIR BAG CLOCKSPRING

There is no summary currently available

Investigation PE95053 Opened 1995-10-25 · closed 1995-12-22

FUEL LEAKEAGE FROM ROLLOVER VALVE

There is no summary currently available

Investigation PE96008 Opened 1996-01-25 · closed 1996-06-28

SAFETY BLT LATCH OPERATION

There is no summary currently available

Investigation PE96051 Opened 1996-08-19 · closed 1997-01-31

FUEL LEAKS FROM THE GAS TANK

ANALYSIS TO DATE INDICATES THAT SOME OF THE SUBJECT VEHICLESCONTINUE TO EXPERIENCE FUEL LEAKS FROM THE FUEL TANK AT THE SENDING UNIT INTERFACE.MOST OFTEN THE LEAK INVOLVES THE O-RING SEAL.

Investigation PE99010 Opened 1999-02-03 · closed 1999-06-11

POST-COLLISION FUEL SYSTEM INTEGRITY

There is no summary currently available

Investigation RQ00008 Opened 2000-03-09 · closed 2002-03-18

DC MINIVAN FUEL INJECTOR RAIL LEAK

There is no summary currently available

Investigation SQ96016 Opened 1996-09-18 · closed 1997-02-04

INTEGRATED CHILD SEAT BELT LOCKUP

ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1996 Plymouth Grand Voyager as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.