The 1998 Plymouth Voyager has 5 NHTSA recall campaigns affecting an estimated 4,165,076 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 443 complaints with NHTSA, most often about the power train. Last updated July 5, 2026.
Recall campaigns
AIR BAGS04V4800002004-10-06955,344 affected
Defect
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence
THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy
DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS…
AIR BAGS02V2930002002-11-071,500,521 affected
Defect
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence
THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy
DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. …
SEAT BELTS02V0760002002-03-08545,311 affected
Defect
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence
IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy
DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT…
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy
DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE…
CHILD SEAT97V2310001997-12-15900 affected
Defect
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.
Consequence
THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.
Remedy
DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.
Complaints by component
POWER TRAIN:AUTOMATIC TRANSMISSION
40
2crashes1fires1injuries
AIR BAGS
35
3crashes6injuries
ENGINE AND ENGINE COOLING:ENGINE
26
1crashes1fires
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
20
AIR BAGS:FRONTAL
18
7crashes6injuries
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
16
8fires
UNKNOWN OR OTHER
16
1crashes1injuries
ELECTRICAL SYSTEM:HORN
13
ENGINE AND ENGINE COOLING
12
1fires
ELECTRICAL SYSTEM
11
1injuries
Total complaints443
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The 1998 plymouth voyager passenger van was involved in a two vehicle collision on a public highway. Cause of the collision was due to the other involved vehicle, that being a 2011 kia soul, failing to stay within its travel lane. The kia crossed over into the path of the plymouth voyager, with…”
“1998 plymouth voyager left and right front towers are consumed by corrosion exposing the strut assemblies and severely weakening the load bearing structure causing serious risk of strut tower failure as on or both struts will penetrate into the engine compartment causing the front of the vehicle…”
“Tl* the contact owns a 1998 plymouth voyager. While driving at 45 mph, the air bag warning light illuminated and the cruise control failed. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The failure mileage was 140,000. The vin was not available.”
“Tl* the contact owns a 1998 plymouth voyager. The contact stated that while driving 45 mph during inclement weather, the serpentine belt slipped off the pulley, causing the battery warning light to illuminate. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure…”
“1989 plymouth voyager left and right front towers are consumed by corrosion exposing the mcpherson strut assemblies and severely weakening the load bearing structure causing serious risk of strut tower failure as on or both struts will penetrate into the engine compartment causing the front of the…”
“1989 plymouth voyager left and right front towers are consumed by corrosion exposing the mcpherson strut assemblies and severely weakening the load bearing structure causing serious risk of strut tower failure as on or both struts will penetrate into the engine compartment causing the front of the…”
“The belt slips off in the rain causing power failure to everything running off the belt. No power steering, no cooling system, no electrical charging, no a/c, and I believe the brakes didn't work right. *tr”
“Another 1998 plymouth voyager van with the rear brake lines broken. Happened on the road, brakes worked and less than 3 miles down the road when driver attempted a turn, brakes went to the floor. Driver was able to park the vehicle. Vehicle was driven home by husband using front brakes only where…”
Defect investigations
InvestigationEA01007 Opened 2001-02-21 · closed 2002-11-22
AIR BAG CLOCKSPRING
There is no summary currently available
InvestigationEA04013 Opened 2004-06-04 · closed 2005-05-25
DRIVER AIR BAG CLOCKSPRING FAILURE
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND…
InvestigationEA99013 Opened 1999-06-11 · closed 2001-08-10
POST COLLISION FUEL SYSTEM
InvestigationPE02004 Opened 2002-01-16 · closed 2002-03-11
REAR SEAT BELT MALFUNCTION
THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS…
InvestigationPE99010 Opened 1999-02-03 · closed 1999-06-11
POST-COLLISION FUEL SYSTEM INTEGRITY
There is no summary currently available
InvestigationRQ00008 Opened 2000-03-09 · closed 2002-03-18
DC MINIVAN FUEL INJECTOR RAIL LEAK
There is no summary currently available
InvestigationRQ04001 Opened 2004-01-28 · closed 2004-06-04
DRIVER AIR BAG CLOCKSPRING FAILURE
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1998 Plymouth Voyager as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.