RecallRepo

1999 Pontiac Bonneville Recalls

Recalls on record Updated July 2026

The 1999 Pontiac Bonneville has 3 NHTSA recall campaigns affecting an estimated 1,010,558 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 176 complaints with NHTSA, most often about the engine and engine cooling. Last updated July 5, 2026.

Recall campaigns

FUEL SYSTEM, GASOLINE 04V090000 2004-02-24 910,873 affected
Defect

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE…

Consequence

THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.

Remedy

DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.

POWER TRAIN 99V089000 1999-04-26 99,333 affected
Defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 4T65E AUTOMATIC TRANSMISSIONS. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE." A RETAINING CLIP, WHICH SECURES THE MANUAL VALVE TO THE LINKAGE OF THE TRANSMISSION DETENT LEVER, CAN BECOME LOOSE UNDER A…

Consequence

IF THE LINK DISCONNECTS, THE DRIVER'S INDICATED PRNDL STATE MAY DIFFER FROM THE HYDRAULIC STATE OF THE TRANSMISSION. IF THE DRIVER SELECTS 'DRIVE' AND THE TRANSMISSION IS ACTUALLY IN 'REVERSE', A VEHICLE CRASH COULD OCCUR.

Remedy

DEALERS WILL REPLACE THE MANUAL VALVE/LINK ASSEMBLY WITH A REPLACEMENT MANUAL VALVE/LINK KIT, FEATURING A SPRING-TYPE FASTENER.

WHEELS 99V072000 1999-04-12 352 affected
Defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CHROME PLATED ALUMINUM WHEELS. SOME OF THESE WHEELS HAVE A MOUNTING SURFACE THAT WAS NOT MACHINED CORRECTLY, CAUSING THE WHEEL STUDS TO BREAK.

Consequence

THE TIRE/WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL INSPECT THE WHEELS AND REPLACE ALL WHEELS WITH DATE CODES INDICATING THAT THEY MAY NOT HAVE BEEN MACHINED CORRECTLY. THE WHEEL MOUNTING STUDS AT ANY LOCATION WHERE A SUSPECT WHEEL WAS INSTALLED WILL ALSO BE REPLACED.

Complaints by component

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
18
1fires
ENGINE AND ENGINE COOLING:ENGINE
13
1crashes1fires
ENGINE AND ENGINE COOLING
12
2fires
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
7
1fires
ELECTRICAL SYSTEM:IGNITION
6
ENGINE AND ENGINE COOLING:COOLING SYSTEM
6
FUEL SYSTEM, GASOLINE
6
1fires
POWER TRAIN:AUTOMATIC TRANSMISSION
6
1crashes
FUEL SYSTEM, GASOLINE:DELIVERY
5
AIR BAGS
4
2injuries
Total complaints176

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“' takata recall" driving and the car cut off..after I stop the car and turn the key off. Was able to re start the car. This has happen a few times. This is not a safe thing when driving on the free ways ....I was in motion and on the street. There was a recall on this but was not were of it this…”

ELECTRICAL SYSTEM · reported 2016-09-03

“' takata recall" driving and the car cut off..after I stop the car and turn the key off. Was able to re start the car. This has happen a few times. This is not a safe thing when driving on the free ways ....I was in motion and on the street. There was a recall on this but was not were of it this…”

FUEL/PROPULSION SYSTEM · reported 2016-09-03

“' takata recall" driving and the car cut off..after I stop the car and turn the key off. Was able to re start the car. This has happen a few times. This is not a safe thing when driving on the free ways ....I was in motion and on the street. There was a recall on this but was not were of it this…”

STEERING · reported 2016-09-03

“While stopped on a side street (25 mph zone), the air bags involuntarily deployed. The driver was severely bruised and suffered significant & permanent hearing loss. There are 7 other incident reports filed with the nhtsa for the same event involving a 1999 pontiac bonneville. What does it take…”

AIR BAGS · reported 2014-04-22

“I have been informed by my daughter-in-law that her mother does not buckle her and her sister up. She also allows them to ride on the front seat. Mind you the two girls are only 4 and 5 years of age. I have reported this to social services on numerous occasions . Also the mother drives without a…”

SEAT BELTS · reported 2013-03-07

“I have been informed by my daughter-in-law that her mother does not buckle her and her sister up. She also allows them to ride on the front seat. Mind you the two girls are only 4 and 5 years of age. I have reported this to social services on numerous occasions . Also the mother drives without a…”

SEATS · reported 2013-03-07

“Tl*the driver owns a 1999 pontiac bonneville. The contact stated the driver was traveling approximately 65 mph when the front drivers side air bag deployed involuntarily. The driver suffered minor injuries. The vehicle was taken to an authorized dealer where the contact was informed water was…”

AIR BAGS · reported 2011-05-14

“Upon accelerating onto the highway, after reaching highway speed, vehicle stalls and would not start. Flooding engine, gasoline coming out of exhaust, engine would not restart. After research and replacing leaking lower intake manifold, this was not my problem there was no leak. After more…”

ENGINE · reported 2011-01-08

Defect investigations

Investigation EA02030 Opened 2002-10-22 · closed 2004-03-09

ENGINE COMPARTMENT FIRES

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME…

Investigation EA02030 Opened 2002-10-22 · closed 2004-03-09

ENGINE COMPARTMENT FIRES

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME…

Investigation EA02030 Opened 2002-10-22 · closed 2004-03-09

ENGINE COMPARTMENT FIRES

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME…

Investigation EA07008 Opened 2007-06-12 · closed 2008-05-01

ENGINE COMPARTMENT FIRE

BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67…

Investigation EA07008 Opened 2007-06-12 · closed 2008-05-01

ENGINE COMPARTMENT FIRE

BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67…

Investigation PE02050 Opened 2002-06-13 · closed 2002-10-22

ENGINE COMPARTMENT FIRES

Investigation RQ99007 Opened 1999-05-26 · closed 2002-02-08

TRANSMISSION SHIFT LEVER SEQUENCE

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1999 Pontiac Bonneville as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.