RecallRepo

2001 Volkswagen Passat Recalls

Recalls on record Updated July 2026

The 2001 Volkswagen Passat has 3 NHTSA recall campaigns affecting an estimated 969,284 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 558 complaints with NHTSA, most often about the engine and engine cooling. Last updated July 5, 2026.

Recall campaigns

FUEL SYSTEM, GASOLINE 08V156000 2008-04-07 412,000 affected
Defect

VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE…

Consequence

A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.

Remedy

DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON…

FUEL SYSTEM, GASOLINE 02V026000 2002-01-25 487,284 affected
Defect

ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.

Consequence

FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.

Remedy

DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR…

FUEL SYSTEM, GASOLINE 01V157000 2001-05-03 70,000 affected
Defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN…

Consequence

RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.

Remedy

DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN…

Complaints by component

ENGINE AND ENGINE COOLING:ENGINE
32
ENGINE AND ENGINE COOLING
31
2fires
ELECTRICAL SYSTEM
30
2fires1injuries
ELECTRICAL SYSTEM:IGNITION
20
1fires1injuries
POWER TRAIN:AUTOMATIC TRANSMISSION
20
SERVICE BRAKES, HYDRAULIC
16
AIR BAGS
13
3crashes2injuries
EXTERIOR LIGHTING:HEADLIGHTS
13
FUEL SYSTEM, GASOLINE
12
1fires
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
12
Total complaints558

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“My fuses keep blowing, this is leading to replacing the brake switch which I believe was recalled. If it was replaced,it's not working.”

SERVICE BRAKES · reported 2026-06-18

“The driver's side airbag of my 2001 vw passat spontaneously deployed while I drove on hwy 494 in woodbury mn. Sometime within 24 hours before the airbag deployed, the airbag fault light turned on in the car's dashboard display. Within 15 minutes before the incident, the car's automatic locking…”

AIR BAGS · reported 2021-06-10

“Took car to vw dealer to have timing belt replaced and was notified that there were several open recalls and they offered to take care of them free of charge. However, they were unable to perform recall #08v156. Manufacturer #26e5. They installed the heat shield but could not perform software…”

ENGINE · reported 2020-12-28

“Took car to vw dealer to have timing belt replaced and was notified that there were several open recalls and they offered to take care of them free of charge. However, they were unable to perform recall #08v156. Manufacturer #26e5. They installed the heat shield but could not perform software…”

FUEL/PROPULSION SYSTEM · reported 2020-12-28

“Abs light on and break light flashing”

SERVICE BRAKES · reported 2018-07-18

“Abs light on and break light flashing”

VEHICLE SPEED CONTROL · reported 2018-07-18

“Started smelling gas and mileage started droppi g bad around the end of november. We see that there has been recalls on the gas tank and fuel lines for 01 volkswagen passats but unfortunately not for this vin # which happens to be my sons car. Now its at the shop because its gas mileage went way…”

FUEL/PROPULSION SYSTEM · reported 2017-11-27

“Faulty cam chain tensioner failed and caused severe engine damage to valves, pistons, camshaft, cam timing chain. I was stationary waiting at a red light when I heard a sudden loud grinding noise from inside the engine compartment, the engine began to shake and sputter. The car lost most of its…”

ENGINE · reported 2017-11-10

Defect investigations

Investigation DP05004 Opened 2005-08-11 · closed 2005-12-08

ENGINE STALLING

BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING…

Investigation EA03020 Opened 2003-10-07 · closed 2004-04-23

PASSENGER AIR BAG LID FAILURE

THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA)…

Investigation EA03020 Opened 2003-10-07 · closed 2004-04-23

PASSENGER AIR BAG LID FAILURE

THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA)…

Investigation EA07014 Opened 2007-09-28 · closed 2008-07-07

PASSENGER ENGINE COMPARTMENT FIRES

THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING…

Investigation EA07014 Opened 2007-09-28 · closed 2008-07-07

PASSENGER ENGINE COMPARTMENT FIRES

THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING…

Investigation EA11002 Opened 2011-01-26 · closed 2012-02-17

Engine Compartment Fire

In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and…

Investigation EA11002 Opened 2011-01-26 · closed 2012-02-17

Engine Compartment Fire

In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and…

Investigation PE03021 Opened 2003-05-23 · closed 2003-10-07

PASSENGER SIR DOOR MOUNTING STUD FAILURE

ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW…

Investigation PE07024 Opened 2007-05-10 · closed 2007-09-28

PASSENGER/ENGINE COMPARTMENT FIRES

MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS…

Investigation PE08008 Opened 2008-01-31 · closed 2008-05-30

FUEL TANK LEAK

VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA…

Investigation PE08008 Opened 2008-01-31 · closed 2008-05-30

FUEL TANK LEAK

VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA…

Investigation PE08008 Opened 2008-01-31 · closed 2008-05-30

FUEL TANK LEAK

VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA…

Investigation PE08008 Opened 2008-01-31 · closed 2008-05-30

FUEL TANK LEAK

VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2001 Volkswagen Passat as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.