The 2000 Volvo S80 has 4 NHTSA recall campaigns affecting an estimated 369,802 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 442 complaints with NHTSA, most often about the vehicle speed control. Last updated July 5, 2026.
Recall campaigns
EQUIPMENT10V5660002010-11-08416 affected
Defect
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence
AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy
VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE…
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence
THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy
DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ENGINE AND ENGINE COOLING04V4510002004-09-13149,799 affected
Defect
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequence
A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy
DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
SUSPENSION00V2380002000-08-2449,488 affected
Defect
VEHICLE DESCRIPTION: PASSENGER VEHICLES. OVER TIME, THE BALL JOINT BETWEEN THE FRONT WHEEL KING PIN AND THE SUSPENSION LINK ARM, CAN EXPERIENCE INCREASED LOOSENESS.
Consequence
THIS CONDITION COULD AFFECT THE BALL JOINT'S DURABILITY AND PERFORMANCE.
Remedy
DEALERS WILL REPLACE BOTH FRONT BALL JOINTS.
Complaints by component
VEHICLE SPEED CONTROL
88
3crashes
ELECTRICAL SYSTEM
44
3fires
ENGINE AND ENGINE COOLING
25
2fires
FUEL SYSTEM, GASOLINE
20
1fires
ENGINE AND ENGINE COOLING:ENGINE
19
1fires
POWER TRAIN:AUTOMATIC TRANSMISSION
15
SUSPENSION:FRONT
11
1crashes
AIR BAGS
9
1crashes
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
9
SERVICE BRAKES, HYDRAULIC
9
1crashes
Total complaints442
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The contact owns a 2000 volvo s80. The contact stated that while at a complete stop, the vehicle intermittently hesitated in responding while depressing the accelerator pedal. The contact stated that the check engine warning light was illuminated during the failure. The contact called the dealer…”
“Swapped battery at o'reilly's auto parts. All manufacturer safety protocols followed. After swapping out w/new battery: climate control module not working- srs airbag 'service urgent' errors. Volvo quoting $2500 to replace ccm, $800 for rebuild-process. Dim is also fried. No heat or a/c- airbag…”
“Swapped battery at o'reilly's auto parts. All manufacturer safety protocols followed. After swapping out w/new battery: climate control module not working- srs airbag 'service urgent' errors. Volvo quoting $2500 to replace ccm, $800 for rebuild-process. Dim is also fried. No heat or a/c- airbag…”
“Swapped battery at o'reilly's auto parts. All manufacturer safety protocols followed. After swapping out w/new battery: climate control module not working- srs airbag 'service urgent' errors. Volvo quoting $2500 to replace ccm, $800 for rebuild-process. Dim is also fried. No heat or a/c- airbag…”
“I want to make you aware of a very serious car accident that my mother had on 9-5-18. She was driving her 2000 volvo s80 when her car began to accelerate on its own. She was not able to control the car. My mom had her foot on the brake but that did not stop the vehicle. Unfortunately, at that…”
“Vehicle has the smell of fuel. The 2001-2005 models have a recall for this same issue because of the plastic on the fuel pump flange cracking. Many owners of the 2000 models are reporting this issue. The fuel pump is the same used on the 2000 year model as the 2001-2005 so the 2000 should be part…”
“I was driving and my car lights and all the electronic stop working and turn off”
“I was driving and my car lights and all the electronic stop working and turn off”
Defect investigations
InvestigationEA05021 Opened 2005-12-06 · closed 2006-12-12
THROTTLE CONTROL MALFUNCTION
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR…
InvestigationPE05041 Opened 2005-07-26 · closed 2005-12-07
THROTTLE CONTROL MALFUNCTION
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2000 Volvo S80 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.