The 2007 Volvo S80 has 5 NHTSA recall campaigns affecting an estimated 333,020 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 32 complaints with NHTSA, most often about the structure. Last updated July 5, 2026.
Recall campaigns
SEAT BELTS20V3780002020-06-30308,260 affected
Defect
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating…
Consequence
An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy
Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
STEERING11V3780002011-07-268,406 affected
Defect
VOLVO IS RECALLING CERTAIN MODEL YEAR 2007 S80 PASSENGER CARS MANUFACTURED FROM MARCH 8, 2006, THROUGH MAY 16, 2007. THE POWER STEERING RESERVOIR RETURN HOSE MAY HAVE BEEN INCORRECTLY ROUTED, WHICH CAN RESULT IN INCREASED PRESSURE IN THE POWER STEERING SYSTEM. THE POWER STEERING RETURN HOSE MAY BURST AT THE STEERING…
Consequence
THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING, INCREASING THE RISK OF A CRASH.
Remedy
VOLVO DEALERS WILL INSPECT THE ROUTING OF THE POWER STEERING RESERVOIR RETURN HOSE AND MAKE REPAIRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2011. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
EQUIPMENT10V5660002010-11-08416 affected
Defect
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence
AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy
VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE…
TIRES10V3350002010-07-223,635 affected
Defect
VOLVO IS RECALLING CERTAIN MODEL YEAR 2007-2010 S80 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE AND LOADING INFORMATION LABEL AND A PAGE IN THE OWNER'S MANUAL CONTAIN INCORRECT MAXIMUM PERMISSIBLE INFLATION PRESSURE AND…
Consequence
THESE VEHICLES DO NOT MEET THE REQUIRED SAFETY STANDARDS.
Remedy
DEALERS WILL UPDATE THE VEHICLES WITH A NEW TIRE AND LOADING INFORMATION LABEL, OWNER'S MANUAL LABEL AND TPMS SOFTWARE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 27, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR CUSTOMERCARE@VOLVOFORLIFE.COM .
VOLVO IS RECALLING 12,303 MY 2007-2008 S80 AND V70 VEHICLES. THE DIAGNOSTIC SOFTWARE IN THE CENTRAL ELECTRONIC MODULE (CEM) MAY CAUSE A MALFUNCTION OF THE WINDSHIELD WIPER FUNCTIONALITY. IF THIS CONDITION OCCURS, THE WINDSHIELD WIPERS MAY NOT OPERATE WHEN ACTIVATED; OR IN CERTAIN CASES THE WINDSHIELD WIPERS MAY…
Consequence
OPERATING A MOTOR VEHICLE DURING INCLEMENT WEATHER CONDITIONS WITHOUT FUNCTIONING WINDSHIELD WIPERS CAN INCREASE THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT THE CEM AND UPGRADE THE SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON MAY 15, 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552, OR CUSTOMERCARE@VOLVOFORLIFE.COM.
Complaints by component
STRUCTURE:BODY
5
ENGINE
4
STEERING
4
ELECTRICAL SYSTEM
3
UNKNOWN OR OTHER
3
EXTERIOR LIGHTING
2
VISIBILITY
2
VISIBILITY/WIPER
2
ELECTRICAL SYSTEM:SOFTWARE
1
FUEL SYSTEM, GASOLINE
1
Total complaints32
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The contact owns a 2007 volvo s80. The contact stated that while operating the vehicle during a rainstorm; rainwater leaked into the vehicle from the top section of the driver's side of the windshield, creating a visibility hazard for the driver. The cause of the failure was not determined. The…”
“The contact owns a 2007 volvo s80. The contact stated that while operating the vehicle during a rainstorm; rainwater leaked into the vehicle from the top section of the driver's side of the windshield, creating a visibility hazard for the driver. The cause of the failure was not determined. The…”
“These generation of volvo p3 platform cars had a defective windshield seal that was not the best from the factory. Many cars of this generation (s60, s80, xc90, etc) have had the seals break, causing extreme water leakage as mine has had. And the possibility of the windshield falling out. Mine is…”
“Warning light on dashboard indicated right front headlamp out. Repair shop removed and replaced original component with new component. Internal inspection of light assembly revealed missing insulation(photos attached) on wiring harness causing a short circuit which also ruined the headlight…”
“Warning light on dashboard indicated right front headlamp out. Repair shop removed and replaced original component with new component. Internal inspection of light assembly revealed missing insulation(photos attached) on wiring harness causing a short circuit which also ruined the headlight…”
“Excessive rust is forming on my front subframe and in some places has rusted completely through. Small perferations were noticed at repair facility and I was told that it will need to be replaced. It cannot be welded/repaired. This is a known problem with the 2007-2010 volvo s80 v8 which volvo…”
“Excessive rust is forming on my front subframe and in some places has rusted completely through. I have a silver dollar sized hole through it and it will need to be replaced. This is a known problem with the 2007-2010 volvo s80 v8 which volvo refuses to recall and will be an extremely costly…”
“Severe subframe rust due to excessive heat from the exhaust on the v8 models of the volvo s80s only. Dealer said the excessive heat will melt the paint off, causing rust to attract to the subframe. The subframe is a critical component to the car, unfortunately although volvo has said this is a…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2007 Volvo S80 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.