The 2010 Volvo S80 has 5 NHTSA recall campaigns affecting an estimated 334,050 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 36 complaints with NHTSA, most often about the visibility/wiper. Last updated July 5, 2026.
Recall campaigns
SEAT BELTS20V3780002020-06-30308,260 affected
Defect
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating…
Consequence
An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy
Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
EQUIPMENT10V5660002010-11-08416 affected
Defect
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence
AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy
VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE…
AIR BAGS10V4890002010-10-139,746 affected
Defect
VOLVO IS RECALLING CERTAIN MODEL YEAR 2010-2011 S80, XC70, MODEL YEAR 2011 XC60 AND MODEL YEAR 2010 V70 VEHICLES. THERE MAY BE AN INTERMITTENT FAULT IN THE DRIVER'S AIRBAG CLOCKSPRING WIRING CONNECTOR FOR THE SUPPLEMENTAL RESTRAINT SYSTEM.
Consequence
IN THE EVENT OF A CRASH, THE DRIVER'S FRONTAL AIRBAG MAY NOT DEPLOY AS INTENDED OR AT ALL, AND THEREFORE WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.
Remedy
DEALERS WILL INSTALL A METAL SHIM IN THE DRIVER'S AIR BAG CLOCKSPRING WIRING CONNECTOR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
TIRES10V3350002010-07-223,635 affected
Defect
VOLVO IS RECALLING CERTAIN MODEL YEAR 2007-2010 S80 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE AND LOADING INFORMATION LABEL AND A PAGE IN THE OWNER'S MANUAL CONTAIN INCORRECT MAXIMUM PERMISSIBLE INFLATION PRESSURE AND…
Consequence
THESE VEHICLES DO NOT MEET THE REQUIRED SAFETY STANDARDS.
Remedy
DEALERS WILL UPDATE THE VEHICLES WITH A NEW TIRE AND LOADING INFORMATION LABEL, OWNER'S MANUAL LABEL AND TPMS SOFTWARE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 27, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR CUSTOMERCARE@VOLVOFORLIFE.COM .
VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE…
Consequence
IF THE VEHICLE STALLS IN CERTAIN CONDITIONS, A CRASH COULD OCCUR.
Remedy
DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Complaints by component
VISIBILITY/WIPER
5
AIR BAGS
3
1crashes2injuries
ELECTRICAL SYSTEM
3
ENGINE
3
STRUCTURE:BODY
3
FUEL/PROPULSION SYSTEM
2
UNKNOWN OR OTHER
2
VEHICLE SPEED CONTROL
2
AIR BAGS:FRONTAL
1
FUEL SYSTEM, GASOLINE
1
Total complaints36
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Car would not crank, got fuel system replaced. Week later after being parked, while driving car cut off on highway. Mechanic has vehicle and has determined the issue is central electronic module. Car is 2010 volvo s80 with active recall but vin number is not apart of recall while experiencing same…”
“On [xxx] I was driving from opelika, al to birmingham, al. About 20 miles from home while driving on [xxx] in the left lane, my car would not accelerate. I pushe9 it down to the floor and there was no gas, so I had to get over to the right lane while rolling to get out of danger of the traffic and…”
“Driving down [xxx] headed west to charlottesville and debris flew off of another truck with a trailer attached . Came off the back of their truck and smashed into the top of my car into my sunroof glass. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6)”
“The contact owns a 2010 volvo s80. The contact stated that there was condensation inside the vehicle. Additionally, the contact's daughter informed the contact that there was mold on the front passenger's side seat belt. The contact stated that there was mold on the lower seal near the front…”
“The air bag warning randomly popped up on my screen. They will not deploy if I get into a wreck. Non working air bag. I also have issues that come and go with the electrical component. Sometimes my door won't open, sometimes my seats won't move, and my license plate light is out due to something…”
“The air bag warning randomly popped up on my screen. They will not deploy if I get into a wreck. Non working air bag. I also have issues that come and go with the electrical component. Sometimes my door won't open, sometimes my seats won't move, and my license plate light is out due to something…”
“The air bag warning randomly popped up on my screen. They will not deploy if I get into a wreck. Non working air bag. I also have issues that come and go with the electrical component. Sometimes my door won't open, sometimes my seats won't move, and my license plate light is out due to something…”
“I was driving down the road at 60mph, and my car started to wobble a little bit. I pulled over to see if something was obviously wrong and I didn't notice anything. At this point I thought that maybe I needed a new rear shock, but when I got back on the road, the wobble was so bad that I couldn't…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2010 Volvo S80 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.