The 2025 Chevrolet Silverado 3500 has 1 NHTSA recall campaign affecting an estimated 11,807 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 19 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.
General Motors, LLC (GM) is recalling certain 2025-2026 Chevrolet Silverado 3500, and GMC Sierra 3500 vehicles with gasoline engines and dual fuel tanks (RPOs L8T and N2N). The rear fuel pump may not transfer adequate fuel to the front tank, causing an engine stall.
Consequence
An engine stall increases the risk of a crash.
Remedy
The vehicle's engine control module (ECM) will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 8, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall…
Complaints by component
ELECTRICAL SYSTEM
3
1fires
POWER TRAIN
3
1fires
SERVICE BRAKES
3
1fires
ENGINE
2
1fires
UNKNOWN OR OTHER
2
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
1
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
1
FUEL/PROPULSION SYSTEM
1
1fires
STRUCTURE:BODY
1
TRAILER HITCHES
1
Total complaints19
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“We were pulling a 5th wheel camper on the highway at 62 mph. We experienced a series of sudden breaking sensations. Engine rpms did not change during these events. We had been traveling for 45 minutes and decided to cancel our camping trip and return home because we were afraid of getting stranded…”
“On april 13, 2026, I experienced two safety-related malfunctions while driving my 2025 chevrolet silverado 3500 ltz on a two-lane highway in light rain. At approximately 6:24:05 pm, the windshield wipers stopped in the upright position for about 2–3 seconds while the vehicle was in motion,…”
“On april 13, 2026, I experienced two safety-related malfunctions while driving my 2025 chevrolet silverado 3500 ltz on a two-lane highway in light rain. At approximately 6:24:05 pm, the windshield wipers stopped in the upright position for about 2–3 seconds while the vehicle was in motion,…”
“On april 13, 2026, I experienced two safety-related malfunctions while driving my 2025 chevrolet silverado 3500 ltz on a two-lane highway in light rain. At approximately 6:24:05 pm, the windshield wipers stopped in the upright position for about 2–3 seconds while the vehicle was in motion,…”
“The vehicle was driven to a job site in gowanda ny. The computer indicated it neede to clean the exhaust filter. The truck was parked in an open area on a blacktop parking area. The truck finished a regen approximately 30 minutes later. The vehicle was shut down and left unattended. Approx 30…”
“The vehicle was driven to a job site in gowanda ny. The computer indicated it neede to clean the exhaust filter. The truck was parked in an open area on a blacktop parking area. The truck finished a regen approximately 30 minutes later. The vehicle was shut down and left unattended. Approx 30…”
“The vehicle was driven to a job site in gowanda ny. The computer indicated it neede to clean the exhaust filter. The truck was parked in an open area on a blacktop parking area. The truck finished a regen approximately 30 minutes later. The vehicle was shut down and left unattended. Approx 30…”
“This truck was parked on a job site, on a flat parking lot over blacktop, doing a regen for the 5th time in just a few days. The truck had 4,000 miles on it. When it completed the regen, we shut the truck off. Within 15 minutes the truck was fully engulfed in flames. A fire investigator looked at…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2025 Chevrolet Silverado 3500 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.